Agricultural and Food Science, Vol. 13 (2004): 247–255. 247 A G R I C U L T U R A L A N D F O O D S C I E N C E Vol. 13 (2004): 247–255. © Agricultural and Food Science Manuscript received March 2004 The effect of free or restricted acidified milk feeding of Finnish Ayrshire bull calves on the subsequent fattening and slaughter performance Hannele Khalili, Marketta Rinne MTT Agrifood Research Finland, Animal Production Research, FI-31600 Jokioinen, Finland, e-mail: hannele.khalili@mtt.fi Pentti Aspila MTT Agrifood Research Finland, FI-31600 Jokioinen, Finland Ilmo Aronen Raisio Nutrition Ltd., PO Box 101, FI-21201 Raisio, Finland The aim of the research was to study whether the anticipated added weight gain from ad libitum acidified milk feeding compared to restricted milk feeding during the preweaning period can be main- tained after weaning until slaughter. The study was conducted by comparing first the growth per- formance of eleven bull calves until an average age of 126 days (Phase 1) when the five calves were fed acidified milk either ad libitum (FM) for 17 weeks or when six calves were given acidified milk restrictively (5 l per day, RM) for nine weeks. Bulls had ad libitum access to grass silage and concen- trate. Secondly, the performance of bulls having an average age of 175 days until slaughter (at an average age of 429 days) at a carcass weight of approximately 290 kg was assessed (Phase 2). All animals were fed grass silage ad libitum and concentrate at a level of 620 g kg-1 of dietary dry matter. Calves fed acidified milk ad libitum grew significantly (P < 0.01) faster than those fed restrictively during the first nine weeks of Phase 1 (1003 vs. 725 g per day). The bulls in the RM group grew a little but not significantly faster during Phase 2, the growth rates being 1197 vs. 1207 g per day. The feed conversion, weight (535 vs. 533 kg at slaughter) and slaughter results were equal. Similarly the life-time gains did not differ being 1174 (FM) and 1141 (RM) g per day, respectively. It can be concluded that the improved performance during early life did not improve growth during the fatten- ing period. Key words: calves, bulls, milk feeding, growth, feed intake, performance 248 A G R I C U L T U R A L A N D F O O D S C I E N C E Khalili, H. et al. Free and restricted milk feeding of bull calves Introduction Free access to whole milk would be the most nat- ural feeding system for both dairy and beef calves. This would, however, also be the most expensive feeding method for preweaned dairy or crossbred calves and therefore feeding based on the restrict- ed use of either milk replacer or whole milk is generally applied to these calves. However, calves can consume high levels of milk e.g. when milk not valid for human consumption is available, when beef or crossbred calves are suckling dams with a high milk yield or when dairy calves are reared under organic regulations (CEC 1999). Increasing intake levels of milk or milk re- placers has improved the live weight gain of preweaned calves (Woodford et al. 1987, Miller et al. 1999, Jasper and Weary 2002). The growth performance over the whole growth period in- cluding both pre- and postweaning is critical from the economic viewpoint as it affects the length of the feeding period needed to attain the target slaughter weight. The amount of milk fed strongly affects the production costs during the preweaning period, since the price of milk is high compared to other feeds and thus it is important to assess how long the growth advantage will be maintained after weaning. Could free access to acidified milk during the calf stage due to anticipated improved perform- ance be an alternative or even superior feeding strategy for dairy breed bull calves through add- ing extra weight until slaughter and improving life-time performance? Does nutritional history affect e.g. the carcass fat grade is also an impor- tant question. There is little data comparing the performance of dairy breed animals from birth to slaughter when milk was given freely or in restricted amounts during the preweaning peri- od. The aim of this experiment was 1) to meas- ure how the anticipated increased weaning weight of bulls fed acidified milk ad libitum is maintained after weaning, 2) to compare feed conversion efficiency and 3) slaughter data of animals with different nutritional history. The study consisted of two phases, the calf-stage (Phase 1) when dairy breed bull calves were fed acidified milk either ad libitum or restrictively, and the fattening stage until slaughter (Phase 2) when the bulls were fed the same diet. Material and methods The study which started in May 1993 was car- ried out indoors in the experimental barn of MTT Agrifood Research Finland in Jokioinen, Fin- land. Twelve bull calves of the Finnish Ayrshire breed were taken into the experiment at an aver- age age of 7 days and having an average live weight of 41.7 kg (±4.3 kg). One animal on free milk (FM) treatment died due to a reason unre- lated to the study so that results of eleven ani- mals were used. All eleven animals remained generally healthy throughout the study. During their first week of life the calves were given whole milk 2 litres twice a day, totalling 10% of body weight. Animals were housed in individu- al pens during the calf stage which lasted for 17 weeks until an average age of 126 days (Phase 1). Calves were randomly allotted to the two experimental treatments. In the free milk feed- ing, the five calves had free access to nipple feed- ing of acidified [3 l of Freeze-dried REDI-SET (Dairy culture: Mesophilic Aromatic Culture Type: LD, CH-N 11) / 40 l of milk] milk (ambi- ent temperature about 20˚C) during the entire Phase 1. In the restricted milk feeding (RM), the six calves were given 2.5 litres of milking-warm acidified milk twice a day (at 0700 and 1600) during the first nine weeks and were weaned thereafter. All the calves had free access to wa- ter, concentrate and grass silage during the en- tire Phase 1. Grass silage was direct-cut from a timothy (Phleum pratense) and meadow fescue (Festuca pratensis) sward and ensiled in bunker silos with a formic acid-based additive applied at a rate of 5 l t-1. The concentrate consisted of barley and a commercial mineral mixture (Se- leeni-Minera, 50 g kg-1 dry matter (DM)) during the first nine weeks and thereafter (weeks 10– 249 A G R I C U L T U R A L A N D F O O D S C I E N C E Vol. 13 (2004): 247–255. 17) a mixture of barley (667 g kg-1 DM), rape- seed meal (267 g kg-1 DM; Raisio Nutrition Ltd., PO Box 101, FIN-21201 Raisio) and a commer- cial mineral mixture (66 g kg-1 DM; Seleeni- Minera). During the Phase 1 there was some oc- casional incidences of diarrhea but in general real health problems were not observed because milk was acidified. After Phase 1 there was a period of an aver- age of 49 days before the beginning of Phase 2 due to technical reasons. The animals were housed indoors in a tie stall barn and they had free access to water, concentrate (the same as in Phase 1 during weeks 10–17) and grass silage. In addition, the calves in the FM group consumed a small amount of milk. The average feed intakes were 0.44 kg DM of milk, 1.46 kg DM of con- centrate and 1.92 kg DM of silage in the FM group and 1.91 kg DM of concentrate and 3.24 kg DM of silage in the RM group. The fattening period (Phase 2) started at an average age of 175 days and lasted until slaugh- ter. The animals were housed indoors in a tie stall barn. The bulls were planned to be slaughtered individually when they reached the target live weight of 550 kg and then the average age of animals was 429 days. Grass silage was given ad libitum. The targeted consumption of concen- trate was 670 g kg-1 of the daily total ad libitum DM intake estimated at the beginning of each four-week period. The concentrate (Raisio Nu- trition Ltd., PO Box 101, FIN-21201 Raisio) consisted of (g kg-1 DM) barley (300), molassed sugar beet pulp (180), wheat bran (90), wheat feed flour (90), rapeseed meal (260), molasses (60) and vegetable oil mixture (20). Feed intake was recorded individually every day in both phases. The calves were weighed weekly in Phase 1. The growing animals were weighed on two consecutive days at the start of Phase 2, every 28 days thereafter and on two consecutive days at the end of Phase 2. Milk sam- ples were taken twice a month and analysed for DM, fat, protein and lactose. The milk composi- tion was analysed using a Milko-Scan 605 ana- lyser (Foss Electric, Hillerød, Denmark). Con- centrate and silage samples for chemical analy- ses were taken at every feeding and pooled for periods of four weeks for concentrate and for periods of two weeks for grass silage. Feed sam- ples were analysed as described by Aronen et al. (1992). At the end of the study, all animals were slaughtered and the carcass weight, dressing % and carcass muscle and fat score were measured. The live weight gains for Phase 1 and 2 were calculated for each animal by difference (end weight – starting weight). The experimental de- sign was a randomised block design having milk feeding strategy as a class variable. The average feed DM intake, growth rate and slaughter data (least squares means) were subjected to analy- sis of variance using the SAS general linear models (GLM) procedure (Littell et al. 1991). Results The average chemical composition of the exper- imental feeds is presented in Table 1. Both the nutritional and ensiling quality of the grass si- lages was good in both phases. The average feed intake in Phase 1 is shown in Table 2. The milk intake of the FM calves was much higher and their concentrate intake lower (P < 0.05) compared to the RM calves. The total DM intake of the FM calves tended (P = 0.08) to be higher compared to those on RM group dur- ing weeks 1–9 resulting in a 1.4 times higher (P < 0.001) intake of metabolizable energy (ME). During weeks 10–17, the calves consumed 4.3 times more concentrates (P < 0.001) and 7.1 times more silage (P < 0.001) in the RM group compared to the calves still having free access to milk. The concentrate intake of the calves in the RM group reached 1.7 kg DM during week 11 and did not increase much thereafter but si- lage intake continued to increase until the end of Phase 1 (Fig. 1). The calves in the FM group doubled their concentrate intake during the last weeks. Because the calves in the FM group con- sumed a great amount of milk (1.51 kg DM), their total DM intake during weeks 10–17 was 250 A G R I C U L T U R A L A N D F O O D S C I E N C E Khalili, H. et al. Free and restricted milk feeding of bull calves 251 A G R I C U L T U R A L A N D F O O D S C I E N C E Vol. 13 (2004): 247–255. Fig. 1. Daily intake (kg DM) of concentrate and milk [A] and si- lage [B] of calves given either free milk (FM) or restricted milk (RM) feeding in Phase 1. c = concen- trate, m = milk. Fig. 2. Live weight of calves given either free milk (FM) or restricted milk (RM) feeding in Phase 1. only 60% of that of the calves in the RM group (P < 0.001), showing a 1.98 substitution rate of concentrate plus silage intake to kg milk DM. Animal performance during Phase 1 is shown in Figure 2 and in Table 3. The weights were greater for the calves in the FM group compared to the RM calves during the whole Phase 1 (Fig. 2.). The live weight of the calves in the FM group was 19% higher (P < 0.01) than those in the RM group at the end of week 9, but at the end of week 17 the difference was reduced to 7%. The daily gain of the calves in the FM group was higher (1003 vs. 725 g; P < 0.01) during weeks 1–9. The energy conversion was similar 252 A G R I C U L T U R A L A N D F O O D S C I E N C E Khalili, H. et al. Free and restricted milk feeding of bull calves between the groups. The daily gains between Phase 1 and 2 were 1227 g for the FM group and 1107 g for the RM group (not shown in Table). The average feed intake and animal perform- ance during Phase 2 are presented in Table 4. The average feed and nutrient intakes were sim- ilar between the groups. The average proportion of concentrate consumed was 620 g kg-1 DM in both groups. This was slightly lower than the targeted 670 g kg-1 DM. Figure 3 illustrates how the live weights of the bulls in the RM group reached the live weights of the bulls in the FM group at the end of Period 7. During Phase 2, the average total gain, feed and energy conver- sions and slaughter data were similar for both groups. The mean gains during the whole life time were 1174 g for the FM group and 1141 g for the RM group (not shown in Table 4). Discussion During Phase 1 the calves in the FM group were heavier than those in the RM group. The aver- age daily gains of the RM calves were moderate (72% of the daily gain of the FM calves) during weeks 1–9. This difference reflected the lower average total ME intake of the RM calves due to the restricted milk supply (54% of ad libitum consumption). In addition, the high content of absorbed amino acids in milk also explained the difference. Jasper and Weary (2002) reported 0.48 vs. 0.78 kg daily gain for female Holstein calves fed milk restrictively (10% of body weight) or ad libitum for 36 days. Holstein bulls grew similarly faster (0.71 vs. 0.30 kg) when given ad libitum acidified milk replacer vs. reg- ular (sweet) milk replacer at a rate of 10% of body weight (Woodford et al. 1987). These ex- periments clearly show the beneficial effect of free milk supply allowing high intake levels of nutrients of calves to support fast growth in the early stage of life. Although free milk intake by suckling beef calves is a common practice in beef breed pro- duction systems, the real level of milk yield of beef cows is not well defined (Miller et al. 1999). In a beef production system after a 187-day preweaning period, calves of beef cows having a greater genetic potential for milk production 253 A G R I C U L T U R A L A N D F O O D S C I E N C E Vol. 13 (2004): 247–255. were heavier compared to calves of dams hav- ing a lower genetic potential for milk produc- tion (Lewis et al. 1990). Miller et al. (1999) also reported that increased milk yield of beef cows was associated with increased preweaning gain and biological efficiency of growth of the calves. During the last eight weeks of Phase 1, the FM animals consumed little concentrate and a negligible amount of silage due to the high av- erage milk intake. This demonstrated a high sub- stitution rate (1.98) of concentrate plus silage DM intake to kg milk DM. During that time calves in the RM group who had been weaned increased greatly their intake of both concentrate and silage. This increased the energy intake of the RM calves and allowed doubling their aver- age daily gain. There were, however, no differ- ences in growth rate and energy conversion, be- cause average ME intakes were similar in both groups. It should be pointed out that the average daily gain of both groups during weeks 10–17 was 1404 g, which is a good growth for dairy breed calves and maybe close to their potential. In the study by Jasper and Weary (2002) there were no significant differences in average daily Fig. 3. Live weight of calves given either free milk (FM) or restricted milk (RM) feeding in Phase 2. Length of period is four weeks. 254 A G R I C U L T U R A L A N D F O O D S C I E N C E Khalili, H. et al. Free and restricted milk feeding of bull calves gains (0.68 ad libitum vs. 0.85 kg conventional milk feeding 10% of body weight) and average intakes of barley-based starter (1.85 vs. 1.89 kg, respectively) after weaning from day 43 to 63. Their study showed that a high milk consump- tion before weaning did not decrease the starter intake after weaning. The average daily gains were quite similar during the seven-week period between Phase 1 and 2. The bulls in the FM group were 11.4 kg and 14.0 kg heavier at the end of Phase 1 and at the beginning of Phase 2, respectively. This showed that this period did not change the cir- cumstances before Phase 2, since the difference was still present at the beginning of Phase 2. In the intensive feeding system prevailing during Phase 2, the bulls in the FM group were not able to maintain greater gains and did not show improved energy conversion. Thus these animals did not show superior growth compared to the other group, and at slaughter time the fi- nal weights and carcass quality were similar be- tween the FM and the RM group. Also similar life-time growths (1174 vs. 1141 g per day) dem- onstrated that high consumption of milk in early life cannot be recommended as a superior rear- ing strategy of dairy breed bulls compared to the commonly used restricted milk feeding. Miller et al. (1999) did not observe any ef- fect of the milk yield of the dam (weaning age of 200 days) on the biological efficiency of growth of calves in the feedlot until slaughter, but they reported larger carcasses. Calves suck- led by dams in the high-milk group maintained, during 280 days in the feedlot growth period to slaughter, 63% of their weaning-weight advan- tage (age 205 days) over those in the low milk group (Clutter and Nielsen 1987). These studies were conducted using beef breed animals with considerably longer milk feeding periods, and therefore these results may not be directly com- parable to the present situation. In conclusion, in Phase 1 calves having ac- cess to free milk supply consumed a high total amount (154 kg DM) of milk but grew faster than restrictively fed calves only during the first nine weeks. After that restrictively fed bulls were able to catch up the difference in daily gain by a slightly faster (non-significant difference) live weight gain, demonstrating that the restriction of early growth did not depress subsequent growth. In this study, the final growth and slaugh- ter results were equal for both groups, revealing that the slight restriction of growth during the preweaning period had no negative carry-over effects on the later performance of the animals. The results showed that the nutritionally most suitable but also very expensive ad libitum milk feeding of dairy calves during the preweaning period did not exhibit superior subsequent per- formance during the fattening period. Thus the final performance of dairy bull calves raised for beef production was not dependent on the milk feeding strategy implemented during the calf stage. References Aronen, I., Toivonen, V., Ketoja, E. & Öfversten, J. 1992. Beef production as influenced by stage of maturity of grass silage and level of supplementary concen- trates. Agricultural Science in Finland 1: 441–459. Clutter, A.C. & Nielsen, M.K. 1987. Effect of level of beef cow milk production on pre- and postweaning calf growth. Journal of Animal Science 64: 1313–1322. CEC 1999. Council regulation No 1804/1999 supplement- ing regulation No 2092/91 on organic production. Official Journal of the European Communities L222: 1–28. Jasper, J. & Weary, D.M. 2002. Effects of ad libitum milk intake on dairy calves. Journal of Dairy Science 85: 3054–3058. Lewis, J.M., Klopfenstein, T.J., Stock, R.A. & Nielsen, M.K. 1990. Evaluation of intensive vs. extensive systems of beef production and the effect of level of beef cow milk production on postweaning performance. Jour- nal of Animal Science 68: 2517–2524. Littell, R.C., Freund, R.J. & Spector, P.C. 1991. SAS® system for linear models. Cary NC, USA. SAS Insti- tute Inc. 329 p. Miller, S.P., Wilton, J.W. & Pfeiffer, W.C. 1999. Effects of milk yield on biological efficiency and profit of beef production from birth to slaughter. Journal of Animal Science 77: 344–352. Woodford, S.T., Whetstone, H.D., Murphy, M.R. & Davis, C.L. 1987. Abomasal pH, nutrient digestibility, and growth of Holstein bull calves fed acidified milk re- placer. Journal of Dairy Science 70: 888–891. 255 A G R I C U L T U R A L A N D F O O D S C I E N C E Vol. 13 (2004): 247–255. SELOSTUS Vapaan ja rajoitetun maitojuoton vaikutukset ayrshiresonnien kasvuun koko kasvatuskauden aikana ja teurastuloksiin Hannele Khalili, Marketta Rinne, Pentti Aspila ja Ilmo Aronen MTT (Maa- ja elintarviketalouden tutkimuskeskus) ja RavintoRaisio Tässä tutkimuksessa selvitettiin, vaikuttaako vasikka- kauden vapaa maitojuotto maitorotuisten lihanautojen kasvuun ja teurastuloksiin. Kokeessa oli yhteensä 11 vasikkaa, jotka jaettiin kahteen ryhmään. Toinen ryh- mä sai koko vasikkakauden ajan eli 17 viikkoa va- paasti hapatettua maitoa. Toinen ryhmä sai kahdesti päivässä 2,5 litraa hapatettua maitoa 9 viikon ajan, jonka jälkeen ne vieroitettiin. Molemmat ryhmät sai- vat vasikkakaudella vapaasti väki- ja säilörehua. Vasikkakauden jälkeen molemmat ryhmät ruokit- tiin samalla lailla. Väkirehun osuus rehuannoksen kui- va-aineesta oli 620 g/kg ja säilörehua annettiin vapaas- ti. Sonnit teurastettiin keskimäärin 429 pv ikäisinä, jol- loin niiden ruhot olivat keskimäärin 292 kg painoisia. Vapaasti maitoa saaneet vasikat joivat ensimmäis- ten 9 viikon ajan enemmän maitoa kuin rajoitetusti juotetut (1.09 vs. 0.59 kg kuiva-aineena) ja ne kas- voivat nopeammin (1003 vs. 725 g/pv). Vasikkakau- den loppupuoliskolla molemmat ryhmät kasvoivat yhtä nopeasti (vapaasti juotetut 1361 g/pv ja rajoite- tusti juotetut 1447 g/pv). Kasvatuskauden alkaessa keskimäärin 175 pv iäs- sä vapaasti juotetut sonnit olivat keskimäärin 14 kg painavampia (ei merkitsevä ero) kuin rajoitetusti juo- tetut sonnit. Kasvatuskauden aikana ryhmien välillä ei ollut merkitseviä eroja päiväkasvussa, rehun muun- tosuhteessa, kasvatusajan pituudessa eikä teurastulok- sissa. Tulokset osoittavat, että runsaan maidonjuon- nin aiheuttama kasvun nopeutuminen vasikkakaudella ei vaikuttanut myönteisesti lihanautojen kasvuun koko kasvatuskautta tarkasteltaessa. The effect of free or restricted acidified milk feeding Introduction Material and methods Results Discussion References SELOSTUS << /ASCII85EncodePages false /AllowTransparency false /AutoPositionEPSFiles true /AutoRotatePages /All /Binding /Left /CalGrayProfile (Gray Gamma 1.8) /CalRGBProfile (Apple RGB) /CalCMYKProfile (U.S. Sheetfed Uncoated v2) /sRGBProfile (sRGB IEC61966-2.1) /CannotEmbedFontPolicy /Warning /CompatibilityLevel 1.4 /CompressObjects /Tags /CompressPages true /ConvertImagesToIndexed true /PassThroughJPEGImages true /CreateJDFFile false /CreateJobTicket false /DefaultRenderingIntent /Default /DetectBlends true /ColorConversionStrategy /LeaveColorUnchanged /DoThumbnails false /EmbedAllFonts true /EmbedJobOptions true /DSCReportingLevel 0 /EmitDSCWarnings false /EndPage -1 /ImageMemory 1048576 /LockDistillerParams true /MaxSubsetPct 99 /Optimize true /OPM 1 /ParseDSCComments true /ParseDSCCommentsForDocInfo true /PreserveCopyPage true /PreserveEPSInfo true /PreserveHalftoneInfo false /PreserveOPIComments false /PreserveOverprintSettings true /StartPage 1 /SubsetFonts true /TransferFunctionInfo /Apply /UCRandBGInfo /Preserve /UsePrologue false /ColorSettingsFile (Color Management Off) /AlwaysEmbed [ true ] /NeverEmbed [ true ] /AntiAliasColorImages false /DownsampleColorImages true /ColorImageDownsampleType /Bicubic /ColorImageResolution 300 /ColorImageDepth 8 /ColorImageDownsampleThreshold 1.50000 /EncodeColorImages true /ColorImageFilter /FlateEncode /AutoFilterColorImages false /ColorImageAutoFilterStrategy /JPEG /ColorACSImageDict << /QFactor 0.15 /HSamples [1 1 1 1] /VSamples [1 1 1 1] >> /ColorImageDict << /QFactor 0.15 /HSamples [1 1 1 1] /VSamples [1 1 1 1] >> /JPEG2000ColorACSImageDict << /TileWidth 256 /TileHeight 256 /Quality 30 >> /JPEG2000ColorImageDict << /TileWidth 256 /TileHeight 256 /Quality 30 >> /AntiAliasGrayImages false /DownsampleGrayImages true /GrayImageDownsampleType /Bicubic /GrayImageResolution 300 /GrayImageDepth 8 /GrayImageDownsampleThreshold 1.50000 /EncodeGrayImages true /GrayImageFilter /FlateEncode /AutoFilterGrayImages false /GrayImageAutoFilterStrategy /JPEG /GrayACSImageDict << /QFactor 0.15 /HSamples [1 1 1 1] /VSamples [1 1 1 1] >> /GrayImageDict << /QFactor 0.15 /HSamples [1 1 1 1] /VSamples [1 1 1 1] >> /JPEG2000GrayACSImageDict << /TileWidth 256 /TileHeight 256 /Quality 30 >> /JPEG2000GrayImageDict << /TileWidth 256 /TileHeight 256 /Quality 30 >> /AntiAliasMonoImages false /DownsampleMonoImages true /MonoImageDownsampleType /Bicubic /MonoImageResolution 1200 /MonoImageDepth -1 /MonoImageDownsampleThreshold 1.50000 /EncodeMonoImages true /MonoImageFilter /CCITTFaxEncode /MonoImageDict << /K -1 >> /AllowPSXObjects false /PDFX1aCheck false /PDFX3Check false /PDFXCompliantPDFOnly false /PDFXNoTrimBoxError true /PDFXTrimBoxToMediaBoxOffset [ 0.00000 0.00000 0.00000 0.00000 ] /PDFXSetBleedBoxToMediaBox true /PDFXBleedBoxToTrimBoxOffset [ 0.00000 0.00000 0.00000 0.00000 ] /PDFXOutputIntentProfile (None) /PDFXOutputCondition () /PDFXRegistryName (http://www.color.org) /PDFXTrapped /Unknown /Description << /FRA /JPN /DEU /PTB /DAN /NLD /ESP /SUO /ITA /NOR /SVE /ENU >> >> setdistillerparams << /HWResolution [1200 1200] /PageSize [595.276 841.890] >> setpagedevice