Ensiled slaughter offal as a protein source for growing pigs Kirsi Partanen, Timo Alaviuhkola and Matti Näsi Partanen, K., Alaviuhkola, T. & Näsi, M. 1992. Ensiled slaughter offal as a protein source for growing pigs.Agric. Sci. Finl. 1; 547-558. (Univ. Helsinki, Dept. Anim. Sei., SF-00014 University of Helsinki and Agric. Res. Centre of Finland, Swine Res. Sta., SF-05840 Hyvinkää, Finland.) The present study was conducted in order to evaluate the use of slaughter offal preserved by lactic acid fermentation in pig diets. Offal was first ground, autoclaved, and mixed with 70 kg sugar beet molasses per 1000 kg. After that it was inoculated with 2x105 lactic acidbacteria/g and incubated at 35°C for three days. The final pH of the fermented product was 3.80. The ensiled slaughter offal (ESO) contained 239 g dry matter (DM)/kg. and 319 g crude protein (CP) and 403 g crude fat (CF)/kg DM. CP contained 47 g lysine, 33 g threonine, 16 g methionine, and 8 g cystine/kg. A digestibility and nitrogen (N) balance assay was conducted with eight barrows using a 2x4 factorial arrangement in a Bx 4 cyclic change-over design. The factors were protein source and protein level. Barley-based diets were supplemented with increasing levels (0, 20,40, and 60 g CP/kg) of ESO or soyabean meal (SBM). Increasing the protein supply led to a linear increase in the digestibility of CP (pcO.OOl) and a quadratic increase in the digestibility of CF (p<0.001). The apparent digestibility of organic matter, CP, and CF calculated by the regression method was 0.811, 0.898, and 0.789 for ESO and 0.849,0.867, and 0.731 for SBM, respectively. N retention increased linearly with increasing protein supply (p<0.001), but no significant differences were observed between protein sources. Although the amount of N excreted in urine was higher (p<0.05) for ESO- than SBM- supplemented diets, there were no significant differences in urea-N excretion between protein sources. The daily weight gain increased linearly with increasing protein supplementation (pcO.OOl) and was higher for SBM- than for ESO-supplemented diets (p<0,05). A growth trial was conducted with 216 pigs using a randomized complete block design. No significant differences were observed in growth performance, feed consumption, or feed conversion rate between the control diet and the test diet. ESO provided 0.20 of DM and 0.22 of feed units of the test diet. Carcass weight and thickness of both back and side fat were similar on both treatments (p>0.05), whereas dressing percentage was higher in pigs fed the test diet (p<0.01). No significant differences were found in the chemical composition or organoleptic scores of the longissimus dorsi muscle between the treatments. Key words: slaughter offal, lacticacid bacteria, preservation, digestibility, performance, pigs 547 1 (1992)Agric. Sei. Fin!. https://www.c-info.fi/en/info/?token=uIxn_JW3Wm87IX7-.YgibA139PHNamF_9cNIaCQ.Yy0t0FLRfBDk1HpoqEEweV-7csXmCUN7aMRNmwnIP-bc_7z9_uESOPwTqqP6Ip7jxQSYkGQ3f-phAktPGfyxUPhDFGdFY0FDPNDmhunWqTBw8NFrNjmbntd0cHm-DqgnLKOE0YdW7l3_dS9AjcUsBhrW9sJq_Mf6pcj7mDCeEomq5odzLtlpaM7pY7HZc-UVkIx2h_5xyvbOcYhTk1PqqFE0lJs214qpHFWBQgSNTwY9JIh_L_5E9XLoBoqT17ja1_PcLL0IKvV_PuYdiMOvqTVkF-6PdlbZ7AvezIKRXE_vHY1i_j6wbN22zw Introduction Fur animal production in Finland has decreased sharply in recent years causing a considerable decline in the demand of fresh slaughter offal for fur animal feed. Consequently, increasing amounts of slaughter offal have been dried to meat and bone meal, which has potential as an important protein source in pig diets because of its high protein con- tent. However, the proportion of meat and bone meal is often limited to 0.05-0.07 in the diets of growing pigs due to its high ash content, poor qual- ity of protein, and large variability in the overall composition and availability of nutrients. For ex- ample, a European survey of 124 samples showed that ash content ranged from 52 to 442 g/kg dry matter (DM), crude protein (CP) from 344 to 738 g/kg DM and lysine from 29 to 70 g/kg CP (Bruy- er et al. 1990). The wide range in nutrient content reflects variations in the proportions of bone, col- lagen and soft tissue in the raw material. The protein of soft tissue is highly digestible with a more desir- able amino acid profde, whereas the protein ofbone and collagen is difficult to digest and has a poorer amino acid profile, despite the high protein content. Danish experiments have shown that the ash con- tent of meat and bone meal is a good indicator of apparent digestibility of the protein, amino acid composition, and energy value. All these properties deteriorate with increasing ash content (Just et al. 1982). Thus, the exclusion of bone from the raw material could effectively improve the nutritional quality of the meal. The processing method, particularly excessive heating, is an important factor affecting the quality of protein in the meal. In the drying process, high temperatures are needed to reduce the high moistu- re content of offal, as well as to kill pathogenic microbes. It has been shown that intense drying , applying a high temperature and pressure, reduces the digestibility of nitrogen and the availability of amino acids considerably (BATTERHAM et al. 1986, Knabe et al. 1989). It has been suggested that amino acids may react with other compounds dur- Slaugter offal Grinding � Autoclaving 130°C, 30 min Addition of carbohydrate (7% sugar beet molasses) i Addition of starter culture 2 * 105 lactic acid bacteria/g Incubation at 35°C (3 days) Fermented product pH 3.7-3.9 Fig. 1. Process of ensiling slaughteroffal. ing the heating process, resulting in chemically mo- dified amino acids. These modified amino acids may have a decreased digestibility and absorption generally, or they may be absorbed in forms that are utilized inefficiently (Batterham et al. 1990, Moughan 1991). Because of the negative effects of drying on the quality of protein in slaughter wastes, continuous attempts have been made to find alternative preser- vation methods to obtain animal feed ingredients with a high nutritive value and hygienic quality. Recently, more interest has been shown towards preservation using organic acids and lactic acid fermentation. Studies have indicated that lactic acid fermentation is suitable for the preservation of poultry offal (TIBBETTS et al. 1987,RUSSELL et al. 1992) as well as cattle and swine offal (Skrede and Nes 1988). Because of its high moisture content, slaughter offal is very susceptible to deterioration caused by bacteria and endogenous enzymes re- leased from animal tissue. Thus, if the offal is fer- mented with lactic acid bacteria, it is necessary to add fermentable carbohydrates to ensure a rapid drop of pH below 4.0 (RUSSELL et al. 1992). The offal may also contain dangerous pathogens and is, therefore, considered an environmental contam- 548 Agric. Sei. Finl. 1 (1992) Table I. Composition of diets in Experiment 1. Diet 12 3 4 5 6 7 8 Protein supplement ESO-O ESO-20 ESO-40 ESO-60 SBM-0 SBM-20 SBM-40 SBM-60 CP, g/kg DM 105 125 145 165 105 125 145 165 Barley DM, g/kg 800 800 800 800 800 800 800 800 Barley starch DM, g/kg 200 134 68 2 200 160 120 80 Ensiled slaughter offal DM, g/kg 0 66 132 198 Soyabean meal DM, g/kg - - - - 0 40 80 120 ESO = ensiled slaughter offal, SBM = soyabean meal inant. However, it has been shown that fermenta- tion with lactic acid bacteria destroys certain patho- genic bacteria and viruses (Wooley et al. 1981, Shotts et al. 1984). This study was conducted to evaluate the nutri- tive value of slaughter offal, ensiled with sugar beet molasses and lactic acid bacteria, for growing pigs. Material and methods Ensiling of slaughter offal Fresh slaughter offal, consisting mainly of internal organs and digestive tracts of slaughtered cattle, was collected froman abattoir, and then ground and autoclaved at 130°C for 30 minutes. After auto- claving, part of the fat was mechanically removed from the surface and sugar beet molasses was added to the hot offal (70 kg per 1000 kg). This mixture was cooled down to 35°C and a commercial lactic acid bacteria culture (Medipharm Stabisil, 20*109 lactic acid bacteria/g) was added at a rate of 10 g per 1000 kg to give 2x105 lactic acid bacteria/g. The offal was then fermented in anaerobic silos for three days. The ensiling process is shown in Figure 1. The ensiled slaughter offal (ESO) was manufactu- red by Ab Feora Oy in Uusikaarlepyy. The ESO used in Experiment 1 was frozen after three days of fermentation to ensure the homogen- ous composition of the feed throughout the trial. In Experiment 2, the ESO was transported weekly to the farm and stored in covered plastic containers. Animals, diets and experimental procedures Experiment I A digestibility and nitrogen (N) balance assay was conducted with eight Large White x Landrace bar- rows using a 2x4 factorial arrangement in a Bx4 cyclic change-over design to compare ESO and soyabean meal (SBM) as a protein supplement for growing pigs. The pigs were kept in metabolism cages throughout the trial, which allowed separate quantitative collection of urine and faeces. Each period comprised five days of adjustment and five days of collection. The live weight of the pigs was 41 kg at the beginning and 71 kg at the end of the trial. The average weight gain was 730 g/d. The experimental diets consisted of a fixed amount of barley and an increasing amount of ESO or SBM (0, 20, 40 and 60 g supplemented CP/kg DM). The diets were adjusted by barley starch to give the same amount of dry matter per day. The composition of the experimental diets is shown in Table 1. The daily ration was 1.8. 2.0, 2.2 and 2.4 kg DM/pig/d in periods 1 to 4, respectively. The pigs were given 40 g mineral and vitamin mixture (Seleeni-Minera) and 18-30 g calcium carbonate/d based on live weight to meet the mineral and vita- min requirements (Salo et al. 1990). Experiment 2 A growth trial was conducted in a commercial pig- gery with 224 cross bred pigs using a randomized complete block design. Due to the size of the pig- 549 Agric. Sei. Fin!. 1 (1992) gery, the trial was conducted in two blocks of 112 animals. Eight pigs (four gilts and four barrows) were placed into each pen and the pens were ran- domly allotted to two treatments. The control pigs were fed a diet consisting of700 g barley, 150 g oats and 150 g protein concentrate (Sian-Herkku S -tiiviste, 400 g CP/kg) per kg. The test pigs were fed ESO and a feed mixture, which consisted of 700 g barley, 190 g oats, 65 g protein concentrate, 40 g mineral premix (Seleeni-Minera) and 5 g vitamin premix (Terviemix) per kg. Feed- ing was carried out according to the age of the animals using a scale from 1.1 to 2.8 feed units/pig/d (FU = 0.7 starch equivalents). The daily portion of ESO was 1.0 kg wet weight per animal for the first three weeks of the trial and 1.5 kg from then onwards. Both diets were calculated to give the same amount of net energy per day. The calcu- lated digestible crude protein (DCP) content of the control diet was 132 g/kg. The DCP content of the test diet declined as the trial advanced, but during the whole trial it was calculated to be 132 g/kg on average. The pigs were weighed at 0,4, 8, and 12 weeks from the beginning of the trial. They were fed to approximately 95 kg live weight and then slaugh- tered. At slaughter, the carcass weight and thick- ness of both back and side fat were measured on cold carcasses. Samples were taken from the ton- gissimus dorsi muscle before the last rib from 10 randomly selected carcasses per treatment. The samples were frozen (-18°C) to await chemical ana- lysis and organoleptic grading. Chemical analyses and calculation of feeding value The chemical analyses of the feeds and faeces were conducted according to standard procedures (Aoac 1984). Crude fat (CF) was determined after acid hydrolysis. Fresh ESO was analyzed for pH, redu- cing sugars (Somogyi 1945,Salo 1965) and lactic acid (Barker and Summerson 1941). The DM content of ESO was corrected for the loss of lactic acid in oven drying according to Porter et al. (1984). The amino acid and mineral analyses of ESO were performed as described by NÄSI (1988). The apparent digestibility of barley starch was assumed to be 1.00, while the digestibility coeffi- cients of ESO and SBM were calculated by the regression and difference methods (Schneider and Platt 1975). The feeding value of the experimen- tal feeds was calculated as feed units according to Salo et al. (1990) and as metabolizable (ME) and net energy (NE) values according to Andersen and Just (1983). The count of total bacteria and coliforms in ESO were determined four times during the growth trial (Valtion maatalouskemian laitos 1981). Analyses of meat samples Frozen samples of the longissimus dorsi muscle were thawed in a coolerfor 24 hours and allowed to warm up to room temperature for two hours. The chemical analyses of the meat samples were per- formed according to standard procedures (AOAC 1984). For organoleptic grading, the longissimus dorsi muscle was cut into 15 mm thick slices, which were fried at 200°C for 1 min 40 s on one side and 2 min on the other. A test panel graded the fried samples for tenderness, juiciness, taste and colour using a 7 point rating scale (tenderness: l=very tough, 7=very tender; juiciness: l=very dry, 7=very juicy; taste: l=very poor, 7=very good; colour: l=very pale, 7=very dark). Statistical analyses The data of the digestibility and nitrogen balance assay were subjected to an analysis of variance using the following model (Snedecor and Coch- ran 1989): Yjjk +Aj+Pj + Tk + eijk 550 Agric. Sd. Fint. 1 (1992) Table 2. Chemical composition of feeds in Experiment 1. ESO SBM B BS ESO Dry matter, g/kg 293 892 877 996 Amino acids, g/kg CP Alanine 58 Composition of dry matter, g/kg Arginine 55 Ash 56 62 26 1 Aspartic acid 71 Crude protein 319 492 128 5 Cystine 8 Crude fat 403 72 35 7 Glutamic acid 151 Crude fibre 23 68 49 8 Glycine 86 Nitrogen-free extract 199 306 762 979 Histidine 18 Isoleucine 32 Sugars 101 Leucine 63 Lactic acid 106 Lysine 47 Methionine 16 Minerals, g/kg DM Phenylalanine 32 Calcium 1.62 Proline 62 Phosphorus 3.49 Serine 37 Magnesium 2.64 Threonine 33 Potassium 15.30 Tyrosine 24 Sodium 5.75 Valine 43 ESO = ensiled slaughter offal, SBM = soyabean meal, B = barley, BS = barley starch. where p = overall mean, A; = effect of animal i, Pj = effect of period j, Tk = effect of treatment k and eijk = residual error. The degrees of freedom for treatment effects were further partitioned into sin- gle degrees of freedom by making orthogonal con- trasts as follows: Cl = ESO diets vs SBM diets (effect of protein source), C 2 = linear effect of protein level, C 3 = quadratic effect ofprotein level, C 4 = cubic effect of protein level, C 5 = interaction ClxC2, C 6 = interaction ClxC3, C 7 = interaction ClxC4. Because there were no significant cubic effects (C4) or their interactions withprotein source (C7), these were omitted from the tables. The data of the growth trial were studied by an analysis of variance using the following model (Snedhcor and Cochran 1989): Yij |i + Bi + Tj + eij where |4 = overall mean, Bj = effect of block /, Tj = effect of treatment j and ey = residual error. The initial weight of a pig was used as a covariate in analyzing weight gain, feed consumption and feed conversion rate. A pen was considered one experi- mental unit. Results and discussion Experiment 1 The chemical composition of the feed ingredients in Experiment I is given in Table 2. After three days of fermentation, the fermented product had a pH of 3.80 and contained 106 g lactic acid and 101 g reducing sugars/kg DM. Although some sugars were left from fermentation, the low pH and high lactic acid content indicate that ESO was well fer- mented. The product was in liquid form and had a primarily sour odour. ESO was found to contain 319 g CP/kg DM, which is less than the values reported for meat meal and meat and bone meal by Salo et al. (1990). The lower CP content partly reflects the addition of sugar beet molasses to the offal. On the other hand, the CF content was exceptionally high, 403 g/kg DM, even though part of the fat was removed from the offal before fermentation. The ash content re- mained low, since the ESO had been made from soft offal. The calcium and phosphorus content of ESO was similar to the valuesreported for ruminant 551 Agric. Sei. Finl. 1 (1992) Table 3. Supply of nutrients in Experiment 1. Diet 1 2 3 4 5 6 7 8 Statistical significance Protein supplement ESO-O ESO-20 ESO-40 ESO-60 SBM-0 SBM-20 SBM-40 SBM-60 SEM Cl C 2 C 3 C 5 C6 CP, g/kg DM 105 125 145 165 105 125 145 165 Dry matter, g/d 2077 2077 1961 2152 1978 2066 2109 2080 56.4 NS NS NS NS NS Organic matter 1978 1971 1855 2029 1884 1963 2000 1971 53.2 NS NS NS NS NS Ash 99 106 106 123 94 103 110 113 3.2 NS *** NS NS NS Crude protein 215 254 277 344 202 252 297 333 8.8 NS *** NS NS NS Crude fat 60 114 155 221 56 63 70 73 7.3 *** *** NS *** NS Crude fibre 85 86 83 92 81 89 96 99 2.3 * *** NS ** NS Nitrogen-free extract 1618 1518 1340 1371 1545 1559 1537 1466 37.6 * *** NS * NS Amino acids, g/d Lysine 8.1 10.0 11.2 14.2 7.6 10.5 13.1 15.4 0.36 * *** NS *NS Methionine 3.6 4.3 4.6 5.7 3.4 4.2 4.9 5.4 0.15 NS *** NS NS NS Cystine 4.7 5.0 5.0 5.8 4.4 5.2 5.9 6.5 0.14 ** *** NS ** NS Threonine 7.5 8.8 9.5 11.8 7.0 9.0 10.8 12.3 0.30 NS *** NS NS NS Isoleucine 8.1 9.3 10.0 12.3 7.6 10.0 12.1 13.9 0.31 *** *** NS ** NS g CP/kg DM 103 122 141 160 103 122 141 159 0.03 NS *** NS NS NS gDM/kgW075 103 102 96 107 99 103 104 102 3.2 NS NS NS NS NS ESO = ensiled slaughter offal, SBM = soyabean meal. SEM =standard error of mean. Contrasts: Cl = ESO vs. SBM (effect of protein source), C 2 = linear effect of protein level, C 3 = quadratic effect of protein level, C 5 = interaction Cl x C2, C 6 = interaction Cl x C3. Significances: NS (not significant), * (p<0.05), ** (p < 0.01), *** (p < 0.001). Table 4. Apparent digestibility of nutrients and nitrogen balance ofdiets in Experiment 1. Diet 1 2 3 4 5 6 7 8 Statistical significance Protein supplement ESO-O ESO-20 ESO-40 ESO-60 SBM-0 SBM-20 SBM-40 SBM-60 SEM Cl C 2 C 3 C 5 C6 CP, g/kg DM 105 125 145 165 105 125 145 165105 125 145 165 105 125 145 165 Organic matter 0.851 0.848 0.830 0.826 0.855 0.850 0.851 0.834 0.0045 * *** NS NS NS Ash 0.415 0.455 0.469 0.481 0.420 0.444 0.465 0.471 0.0136 NS *** NS NS NS Crude protein 0.737 0.776 0.782 0.794 0.748 0.764 0.800 0.789 0.0110 NS*** NS NS NS Crude fat 0.482 0.620 0.670 0.700 0.455 0,479 0.509 0.506 0.0110 ************ * Crude fibre 0.061 0.073 -0.001 0.028 0.078 0.103 0.142 0.082 0.0314 * NS NS NS NS Nitrogen-free extract 0.921 0.920 0.914 0.908 0.924 0.922 0.920 0.912 0.0026 NS*** NS NS NS N intake, g/d 34.4 40.6 44.4 55.0 32.4 40.3 47.5 53.2 1.40 NS*** NS NS NS N excr. in faeces, g/d 8.9 9.0 9.6 11.2 8.2 9.5 9.5 11.2 0.62 NS *** NS NS NS N excr. in urine, g/d 14.8 16,4 18.3 21.2 13,9 16.1 18.3 18.8 0.44 * *** NS NS NS N retained, g/d 10.7 15.2 16.4 22.6 10.3 14.8 19.8 23.2 0.89 NS *** NS NS NS -ofintake 0.310 0.373 0.361 0.411 0.317 0.366 0.417 0.432 0.0139 NS *** NS NS NS -ofabsorbed 0.420 0.480 0.463 0.517 0.424 0.479 0.521 0.548 0.0178 NS *** NS NS NS -g/kgW0' 75 0.52 0.75 0.79 1.13 0.52 0.73 0.97 1.12 0.05 NS *** NS NS NS Urea-N, g/d 11,2 14.6 14.5 17.9 12.9 12.6 15.8 19.4 1.46 NS *** NS NS NS -g/kgW075 0.54 0.72 0.72 0.89 0.65 0.62 0.78 0.97 0.08 NS *** NS NS NS Biological value 0.552 0.584 0.557 0.591 0.558 0.583 0.606 0.623 0.0153 NS*** NS NS NS Weight gain, g/d 464 597 771 758 628 636 957 1007 79.3 * *** NS NS NS ESO = ensiled slaughter offal, SBM = soyabean meal. SEM = standard error of mean. Contrasts: Cl =ESO vs. SBM (effect of protein source), C 2 = linear effect of protein level, C 3 = quadratic effect of protein level, C 5 = interaction Cl x C2, C 6 = interaction Cl x C3. Significances: NS (not significant), *(p < 0.05), ** (p < 0.01), *** (p < 0.001). 552 Agric. Sei. Fint. 1 (1992) Table 5. Apparent digestibility of nutrients calculated by regression (r) and/or difference (d) methods and feed value of ensiled slaughter offal, soyabean meal and barley in Experiment 1. ESO(r) ESO(d) SBM(r) SBM(d) B(d) Organic matter Ash 0.811 0.833 0.849 0.895 0.832 0.731 0.791 0.823 0.886 0.419 Crude protein Crude fat 0.898 0.891 0.867 0.893 0.748 0.789 0.764 0.731 0.693 0.488 Crude fibre O.(XX) 0.000 0.263 0.509 0.072 Nitrogen-free extract I.(X)I 0.942 0.927 0.973 0.912 FU/kg DM kg/FU 1.662 2.06 1.108 1.01 1.121 1.02 DCP g/kg DM DCP g/FU 287 426 96 172 385 85 ME, MJ/kg DM NE, MJ/kg DM FEs 21.50 16.29 14.70 14.25 10.33 9.14 1.846 1.389 1 . 1 85 ESO = ensiled slaughter offal, SBM = soyabean meal, B = barley. FU = 0.7 starch equivalents. ME = metabolizable energy, NE =net energy. offal ensiled with formic acid by Machin et al. (1986). The lysine content of ESO was 47 g/kg CP. This value is lower than those listed for meat meal and meat and bone meal by SALO et al. (1990), whereas JUST et al. (1982) have reported values similar to the present results. The methionine, cystine and threonineconcentrations found in the present study are in agreement with the values reported for meat and bone meal by Just et al. (1982) and Salo et al. (1990). According to SKREDE and NES (1988), lac- tic acid fermentation does not affect the amino acid composition of abattoir waste, which indicates that there is no net synthesis of amino acids by lactoba- cilli. The palatability of ESO was good on all levels of supplementation (Table 3). Increasing the level of protein supplementation in the diet led to a linear increase in the digestibility ofash and CP (p<0.001) and a linear decrease in the digestibility of organic matter and nitrogen-free extract (p<0.001) (Table 4). The increase in the apparent digestibility of CP was similar on both ESO- and SBM-supplemented diets (p>0.05). There was a quadratic increase in the digestibility of CF with increasing protein supplementation (p<0.001). The increase was grea- ter (p<0.05) for ESO- than SBM-supplemented diets. The apparent faecal digestibility of CP calcu- lated by the regression method was 0.898 for ESO (Table 5). The value is higher than those reported in literature for meat and bone meal (Just et al. 1982, Knabe et al. 1989) and fresh slaughter waste (Just et al. 1982).However, both meat and bone meal and fresh waste had a considerably higher ash content than ESO in the present study, which partly ex- plains their lower digestibility. Furthermore, the ESO was made from soft tissues and soft offal protein is highly digestible, and mild heat treatment has been found to cause only slight damage to protein (Haugen et al. 1985). The CP digestibility coefficients reported by Salo et al. (1990) range from 0.84 to 0.92 for meat meal and from 0.82 to 0.84 for meat and bone meal. The apparent faecal digestibility of CP in SBM determined in the present study (0.867) is in agree- ment with the results of Just et al. (1983) and Knabe et al.(1989). 553 Agric. Sei. Fint. 1 (1992) The N excretion, N retention, urea-N excretion and protein utilization were found to increase lin- early with increasing N intake, as expected (pcO.OOl). The increase in N retention was similar on both ESO- and SBM-supplemented diets (p>0.05). The N excretion in urine was higher for ESO- than for SBM-supplemented diets (p<.os). However, the urea-N excretion, which gives an indication of the amino acid balance in the diet, was similar on both protein sources (p>.os). The supply of lysine (p<0.05), cystine, histidine (p<0.01), iso- leucine and phenylalanine (pcO.OOl) was smaller on ESO than SBM diets. Lysine is the first limiting amino acid in barley based diets (Fuller et al, 1979). The calculation of amino acid supply is based on the analyzed levels of amino acids in ESO (Table 3) and the amino acid contents reported by Salo et al. (1990) for soyabean meal and barley. Daily weight gain increased linearly (p<0.00l) with increasing protein supplementation and was slightly higher for SBM- than for ESO-supple- mented diets (p<0.05). Although the digestibility of CP was similar for both protein sources, the differ- ences in amino acid supply may have been in part responsible for the poorer performance on the ESO- supplemented diet. However, the recording period may have been too short to show the full perform- ance. The calculated ME and NE values were 20.28 and 13.33 MJ/kg DM for ESO and 14.98 and 9.35 MJ/kg DM for SBM. respectively (Table 5). Other experiments have given ME values of 15.34 MJ/kg DM for soyabean meal (Just et al. 1983), 9.67 MJ/kg DM for meat and bone meal and 11.36 MJ/kg DM for fresh slaughter waste (JUST et al. 1982). The considerably higher energy value of ESO compared to meat and bone meal and fresh slaughter waste is due to its high fat and low ash content. Experiment 2 In Experiment 2, the average composition of ESO was 301±18.3 g DM/kg, 317± 22.6 g CP, 480 ±49.7 g CF and 46+3.9 g ash/kg DM. The content of fat varied the most, from 114 to 534 g CF/kg DM. When the fat content is high, it may limit the use of offal silage in pigs’ diets. However, the fat content can be lowered by selection ofraw material and by the separation of fat. Fermentation causes the phys- ical separation of oil, liquid and solid fractions (Russell et al. 1992), as also observed in the pres- ent study. This is of value in decanting the layer of fat from the top to decrease the fat content and increase the protein content, thus making it possible to increase the proportion of offal silage in the diet. The total bacteria count ranged from 61 000 to l.lxloB/g, which is probably due to the high num- ber of lactobacilli in the product. There were fewer than 10 coliforms/g, which shows the good hygie- nic quality of the product. No visible surface growth of mould was observed during the one- week storage on the farm, indicating satisfactory stability of ESO. According to Skrede and Nes (1988) an increasing proportion of bone in slaugh- ter waste reduces the stability of the product. A high fat content can also be critical to the stability of offal silage. Due to fat separation, it is necessary to mix the silage during storage. When oxygen is mixed with the silage it reacts with fatty acids, resulting in a series of reactions called oxidative rancidity. The end products of oxidation have a strong odour and flavour which reduces the pay- ability of fat (Enser 1984). A high fat content may also reduce the flow characteristics of offal silage especially at low ambient temperatures. The performance data for the pigs in Experiment 2 are shown in Table 6. Two pigs were removed from the control group due to poor appetite. One pig died and five pigs were excluded from the test group for the following reasons: lung infection, tail biting, swine erysipelas and poor appetite (two pigs). No significant differences were observed in daily weight gain and number of days on trial be- tween the control diet and the test diet. However, the protein concentration of the test diet decreased gradually towards the end of the growing period, 554 Agric. Sd. Finl. 1 (1992) Table 6. Performance, feed consumption and carcass parameters ofpigs in Experiment 2. Control Test SEM Statist. Signif. No. of pigs 110 106 Initial weight, kg 23.2 23.1 1.00 NS Final weight, kg 98.1 97.7 0.41 NS Days on test 105.1 105.0 0.56 NS Live weight gain, g/pig/d 715 711 5.2 NS Total feed, FU '/pig 219 220 1.6 NS Feed, FU/pig/d 2.092.10 0.013 NS Feed conversion, FU/kg 2.922.95 0.020 NS Carcass weight, kg 73.173.5 0.47 NS Dressing, % 74.575.2 0.18 ** Back fat, mm 23.4 23.4 0.40 NS Side fat. mm 15.3 14.9 0.30 NS Longissimus dorsi ~ Chemical composition, g/kg Water 753 753 3.2 NS Fat 13 14 1.0 NS Protein 224 224 3.0 NS Ash 12 12 0.1 NS Organoleptic scores3 Tenderness 4.64.5 0.16 NS Juiciness 4.34.6 0.14 NS Taste 5.05.0 0.09 NS Colour 5.55.4 0.19 NS 1 FU = 0,7 starch equivalents, :10 samples per treatment. 3 Tenderness: l=very tough, 7=very tender; Juiciness: l=very dry, 7=very juicy; Taste: l=very poor, 7=very good; Colour: l=very pale. 7=very dark). SEM=standard error of mean. Significances: NS (not significant), * (p < 0.05), ** (p < 0.01), *** (p < 0.001). whereas that of the control diet remained constant. The former feeding strategy may have been more favourable because of the relative reduction in amino acid requirement during the growing period. ESO provided 0.20 of dry matter and 0.22 of feed units of the test diet. All the pigs, except those excluded for the reasons mentioned above, ate the feeds without difficulty and their health remained good throughout the experiment. The total and daily feed consumption of pigs measured as feed units (Salo et al. 1990) and the feed conversion rate were similar on both diets (p>0.05). The results obtained in the present study are supported by the observations of Machin et al. (1986), who fed growing pigs with different levels of ruminant offal ensiled with formic acid. Their results showed that ruminant offal silage was pala- table to pigs and could provide 0.21 of dietary DM without any negative effect on the pigs’ perform- ance. However, the carcasses tended to get fatter with an increasing level of offal silage in the diet due to the high energy (fat) content of the product. Tibbetts et al. (1987) produced poultry offal silage using Lactobacillus acidophilus and successfully fed it to pigs at the rate of 0.20 of dietary DM. Contrary to the present data Van Lunden et al. (1991) found that an increasing level of acid-pre- served poultry offal in pigs’ diets led to a linear decrease in growth rate due to a decrease in daily feed consumption. In trials, where increasing levels of meat and bone meal replaced soyabean meal in barley based diets, the rate and efficiency of gain of 555 Agric. Sei. Fint. 1 (1992) growing pigs were depressed, despite the fact that the calculated digestible amino acid supplies re- mained the same (Alaviuhkola 1989). It has been suggested that either the digestibility coefficients or the values for amino acid content set down in Finn- ish feed tables (Salo et al. 1990) for meat and bone meal are overestimated. The dressing percentage was found to be higher for the test diet (p<0.01). No significant differences were observed in carcass fatness, contrary to the results of Machin et al. (1986), or in the chemical composition and organoleptic scores of the longis- simus dorsi muscle between the treatments. In conclusion, the results of this study showed that slaughter offal can be successfully ensiled with sugar beet molasses and lactic acid bacteria, and included in pigs’ diets to supply 0.20 ofdietary dry matter without any negative effect on the pigs’ performance. The protein value ofensiled slaughter offal did not differ from that of soyabean meal. However, it is necessary to know the amino acid content of the product, especially that of lysine, in order to make adjustments if required. Compared to the drying process, lactic acid fermentation can provide an alternative low-cost method for preserv- ing slaughter offal. A notable feature of ensiled slaughter offal is its high moisture content and, therefore, although drying costs are avoided, transportation costs become considerably high. Thus, the use of the product is restricted to areas close to the production site. Proper storage, prefer- ably airtight silos, are needed on the farm to ensure the stability of the product. Due to its liquid form, the handling of the product is easiest in liquid feed- ing systems. Acknowledgements. The authors wish to thank Ms. Gun Söderholm and Mr. Kurt Larsson, who cared for the experimental animals. The financial support of Ab Feora Oy is greatfully acknowledged. References Alaviuhkola, T, 1989. Lihaluurehujauho sikojen rehuna. Lihayhtymän tiedotuslehti 2: 15-16. Andersen, P.E. & Just, A. 1983. Tabeller over foderstoffers sammensastning m.m. kvseg, svin. 102 p. Det kgl. danske Landhusholdningsselskab, Kohenhavn. AOAC 1984. Official methods of analysis. 1141 p. Associa- tion of Official Analytical Chemists, Inc., Arlington, Virginia. Barker, S.B. & Summerson, W.H. 1941. The lactic acid in biological material. J. Biol. Chem. 128: 535-554. Batterham, E.S., Andersen, L.M., Baigent, D.R., Beech, S.A. & Elliot, R. 1990. Utilization of ileal digestible amino acids by pigs: lysine, Br, J. Nutr. 64: 679-690. , Darnell, R.E., Herbert, L.S. & Major, E.J. 1986. Effect of pressure and temperature on the availability of lysine in meat and bone meal as determined by the slope- ratio assays with growing pigs, rats and chicks and by chemical techniques. Br. J. Nutr. 55: 441-453. Bruyer, D.C., Foulon, M. & Vanbelle, M. 1990. The amino acid composition of meat and bone meals and its predict- ability. Arch. Anim. Nutr. 40: 259-265. Enser, M. 1984.The chemistry, biochemistry and nutritional importance of animal fats. In: Wiseman, J. (ed.). Fats in animal nutrition. Butterworths, London, pp. 23-51. Fuller, M.F., Livingstone, R.M., Baird, B.A. & Atkinson, T. 1979. The optimal amino acid supplementation of barley for the growing pig. 1. Response of nitrogen me- tabolism to progressive supplementation. Br, J, Nutr. 41: 321-331. Haugen, E.W., Pettigrew, J.E., Cornelius, S.G. & Moser, R.L. 1985.Effecs of meat meal manufacturing variations on amino acid bioavailability in pigs. J. Anim. Sci. 61(Supplement 1): 100. Just, A., Fernandez, J.A. & Jorgensen, H. 1982. Kodben- mels vterdi til svin. 525. Beretning fra Statens Husdyr- brugs forsog. 52 p. , Jorgensen, H., Fernandez, J.A., Bech-Andersen, S. & Enggaard Hansen, N. 1983. Forskellige foderstoffers kemiske sammensastning, fordojelighed, energi- og pro- teinvasrdi til svin. 556. Beretning fra Statens Husdyr- brugs forsOg. 97 p. Knabe, D.A., Larue, D.C., Gregg, E.J., Martinez, G.M., Tanksley, T.D., Jr. 1989. Apparent digestibility of nitro- gen and amino acids in protein feedstuffs by growing pigs. J. Anim. Sci. 67: 441-458. Machin, D.H.. Silverside, D.E., Hector, D.A. & Parr, W.H. 1986. The utilization by growing pigs of ruminant offal hydrolysed in formic acid. Anim. Feed Sci. Tech- nol. 15: 273-284. Moughan, P.J. 1991. Towards an improved utilization of dietary amino acids by the growing pig. In: Haresign, W. & Cole, D.J.A. (eds.). Recent advances in animal nutri- 556 Agric. Sei. Fint. 1 (1992) tion 1991. Butterworth-Heineman, Oxford, p. 45-64. Näsi, M. 1988. Evaluating barley feed fraction from inte- grated ethanol-starch production in diets of ruminants. J. Agric. Sci. Finland 60: 701709. Porter, M.G., Patterson, D.C., Steen, R.W. & Gordon, F.J. 1984. Determination of dry matter and gross energy of grass silage. In: Gordon, F.J. & Unsworth, E.F. (eds.). Proceedings of the 7th silage conference, p. 89-90. Russell, S.M., Fletcher, D.L. & Merka, W.C. 1992. Lactic acid fermentation of broiler processing waste: physical properties and chemical analysis. Poultry Science 71: 765-770. Salo, M.-L. 1965. Determination of carbohydrate fractions in animal foods and faeces. Acta Agric. Fenn. 105: 1-102. —, Tuori, M. & Kiiskinen, T. 1990.Rehutaulukot jaruokin- tanormit. 70 p. Yliopistopaino, Helsinki. Schneider, B.H. & Flatt, P.W. 1975. The evaluation of feeds through digestibility evaluation. 423 p. University of Georgia Press, Athens, Georgia. Shotts, E.8., Jr., Wooley, R.E. & Dickens, J.A. 1984. Anti- microbic effects of Lactobacillus fermentation on edible waste material contaminated with infected carcasses. Am. J. Vet. Res. 45: 24672470. Skrede, A. & Nes, I.F. 1988. Slaughterhouse by-products preserved by Lactobacillus plantarum fermentation as feed for mink and foxes. Anim. Feed Sci. Technol. 20: 287-298. Snedecor, G.W. & Cochran, W.G. 1989. Statistical methods. 503 p. Bth ed. lowa University Press, Ames, lowa. Somogyi, M. 1945. A new reagent for the determination of sugars. J. Biol. Chem. 160: 61-68. Tibbetts, G.W., Seerley, R.W. & McCampbell, H.C. 1987. Poultry offal ensiled with Lactobacillus acidophilus for growing and finishing swine diets. J. Anim. Sci. 64: 182-190. Valtion maatalouskemian laitos 1981. C Rehujen laadun aistinvarainen ja mikrobiologinen tutkimus. In: Valtion maatalouskemiallisen laitoksen tutkimusmenetelmät. Van Lunden, T.A., Anderson, D.M., ST. Laurent, A.-M., Barclay, J. & Nicholson, J.W.G. 1991. The utilization of acid-preserved poultry offal by growing-finishing pigs. Can. J. Anim. Sci. 71: 935-938. Wooley, R.E., Gilbert, T.P., Whitehead, W.K., Shotts, E.8., Jr. & Dobbins, C.N. 1981. Survival of viruses in fermented edible waste material. Am. J. Vet. Res. 42: 87-90. Manuscript received October 1992 Kirsi Partanen Matti Näsi Department of Animal Science P.O. Box 28 SF-00014 University of Helsinki, Finland Timo Alaviuhkola Agricultural Research Centre of Finland Swine Research Station SF-05840 Hyvinkää, Finland 557 Agric. Sei. Fin!. 1 (1992) SELOSTUS Tuoresäilötty teurasjäte lihasikojen valkuaislähteenä Kirsi Partanen, Timo Alaviuhkola ja Matti Näsi Helsingin yliopistoja Maatalouden tutkimuskeskus Tutkimuksessa selvitettiin tuoresäilötyn teurasjätteen käyttö- kelpoisuutta valkuaislähteenä lihasikojen ruokinnassa. Pää- asiassa elimistä jaruoansulatuskanavan kudoksista koostuvaa teurasjätettä kuumennettiin autoklaavissa 130 °C:ssa 30 mi- nuutin ajan. Kuumaan teurasjätteeseen lisättiin 70 kg sokeri- juurikasmelassiaper 1000kg. Seoksen jäähdyttyä siihen lisät- tiin maitohappobakteerivalmistetta ja sen annettiin käydä il- matiiviissä siilossa 3 vrk. Tuoresäilötyn teurasjätteen ravintoaineiden sulavuutta ja valkuaisen hyväksikäyttöä tutkittiin sulavuus- ja typpitaseko- keessa, joka tehtiin 8 lihasialla Bx4 syklisenä jaksokokeena. Sioille syötettiin ohrapohjaisia rehuseoksia, joihin oli lisätty kasvava määrä joko tuoresäilötyn teurasjätteen tai soijarou- heen valkuaista. Dieettien raakavalkuaispitoisuudet olivat 105-165 g/kg ka. Valkuaislähteen osuudella dieetissä oli lineaarinen vaiku- tus ravintoaineiden sulavuuksiin. Raakavalkuaisen sulavuu- dessa ei ollut eroja valkuaislähteiden välillä, mutta raakaras- van sulavuus oli suurempi teurasjätettä sisältävillä dieeteillä. Tuoresäilötyn teurasjätteen raakavalkuaisen sulavuudeksi saatiin regressiomenetelmällä laskettuna 0,898 ja raakaras- van 0,789. Korkeasta rasvapitoisuudesta johtuen tuoresäilö- tyn teurasjätteen energia-arvo oli korkea, 1,66 ry/kg ka. Tuo- resäilötty teurasjäte ja soijarouhe olivat lähes samanarvoisia valkuaislähteitä ohrapohjaisilla dieeteillä. Typen pidättymi- sessä ei ollut eroja valkuaislähteiden välillä. Virtsan typpeä erittyi teurasjätettä sisältävillä dieeteillä enemmän kuin soija- rouhedieeteillä, mutta urea-N erityksessä ei eroa esiintynyt. Tuoresäilöttyä teurasjätettä saaneet siat kasvoivat huonom- min kuin soijarouhe dieeteillä oi leet siat, mikä todennäköisesti johtui pienemmästä lysiinin saannista. Kasvatuskokeessa (226 lihasikaa) vilja-tiiviste -ruokintaa verrattiin ruokintaan, jossa osa tiivisteestä korvattiin tuoresäi- lötyllä teurasjätteellä. Tuoresäilötyn teurasjätteen osuus oli 0,20 rehun kuiva-aineesta. Sikojen kasvussa, rehun kulutuk- sessa jarehun hyväksikäytössä ei ollut eroja ruokintojen välil- lä. Teurastappioprosentti oli suurempi vilja-tiiviste ruokinnal- la, mutta silavan paksuudessa sekä hngissimus dorsi -lihak- sen kemiallisessa koostumuksessa ja aistinvaraisessa laadussa ei ollut eroja ruokintojen välillä. 558 Agric. Sei. Fint. 1 (1992)