Effects of supplemental microbial phytase on performance of broiler chickens Tuomo Kiiskinen, Jari Piironen and Tiina Hakonen Kiiskinen, T. 1, Piironen, J.2 & Hakonen, T. 1 1994. Effects of supplemental microbial phytase on performance of broiler chickens. Agricultural Science in Finland 3; 457-466. ('Agricultural Research Centre of Finland, FIN-31600 Jo- kioinen, Finland, and 2 Alko Ltd. Biotechnology FIN-05200 Rajamäki, Finland.) Three trials were conducted on a total of 5100 broiler chicks (0-5.5 weeks) to study the effects of different microbial phytase (Aspergillus niger) supplementa- tions (250-1000 phytase units = PU/g) on the performance and bone mineralization of birds and on the utilization of phosphorus compared with the effects of mineral P additions as dicalcium phosphate. The basal diets (negative controls) were princi- pally composed of soya bean meal (SBM) and grain (wheat, barley, oats) supple- mented with up to 0.10% mineral P; the positive control diets were supplemented with 0.24-0.30% mineral P. Compared with the negative control groups, which were fed diets with 0.05% mineral P either during the whole rearing period or during the starting period only, phytase addition increased live weight by 4-7% and feed intake by 3-9% (Trials 1 and 2). Tibia values indicated that with low mineral P supplementations (0.05 and 0.10%), phytase additions have a non-significant effect on bone mineralization. If mineral P is not added, the tibia values show a marked response to phytase (Trial 3). Utilization of P increased from 50.9% to 60.0% when phytase (1000 PU/g) was added to the diets without mineral P supplementation (Trial 3). Utilization of P was only 34.5% in the positive control diet (0.3% mineral P). The results were obvious- ly affected by the intrinsic phytase activity in grain and the dietary calcium level, and suggest that, in SBM-grain-based diets with very low (0.05%) or no mineral P supplementation, weight gain can be increased by adding phytase up to 1000 PU/g. This supplemented phytase activity is apparently sufficient for adequate bone min- eralization. Key words: phosphorus, phytic acid, growth, feed efficiency, bone mineralization. mineral utilization Introduction Poultry diets principally consist of feeds of plant origin. Significant amount (50-80%) of the phos- phorus in plant seeds is bound to phytic acid, and the availability for monogastrics such as poultry is low. An availability value of 30% is assigned for phosphorus in plant materials in common use. The earliest studies on the effects of supple- mental microbial phytase in chickens were those of Nelson et al. (1968b, 1971). These authors concluded that the addition of phytase produced by moulds (Aspergillus ficuum) to the diet of chicks hydrolysed phytate phosphorus in the gas- trointestinal tract, enabling the chicks to utilize the liberated phosphorus as well as supplementa- 457 Agricultural Science in Finland 3 (1994) https://www.c-info.fi/en/info/?token=0dl42nV56-2C06Np.EbOHM0JK6tw-b1Q9XiZu_A.59fkfJb6kz8jqTQxAYzUKTHgHSpCeC3lfUrc6ZpUpSD2wgTURfX1F63Ge5KjHVuILuDgWdm3_XYrKYDwW7LKT4xzRiulanFqtJoT4x1q9NQeOHW4dIxJhh8fyc7G-kH97JZ0ItxWNlCVCnCYuaL2QgqwGwgpOOXws3651NmvJ3IWaUFLAZQ32QIMuhV7qxSVRX6hVSEte4COYjlU7S07501bsZ5pfs8uGGXmvo9UZnErQ9azI9f5lBfJyU6gi82HMjrPAn5cxvpA6vDpAyaxebeAfGtCw1WnT5YJuWxHx01DeHHjyV-G ry inorganic phosphorus. In recent years, wide interest has been shown in producing the availa- ble microbial phytases in order to lower the sup- plemental mineral phosphorus and phosphorus content in manure. The addition of microbial phytase (A. ficuum and A. niger) to the diets of poultry, those of growing poultry in particular, has also been studied in greater detail. The addi- tion of phytase to low phosphorus (0.4-0.5% to- tal P) diets of chickens and broilers has markedly increased feed intake and growth rate (Kiiskinen and Piironen 1990, Simons et al. 1990, Swick and Ivey 1990, Saylor et al. 1991, Schöner et al. 1991, Broz et al. 1992, Schöner and Hoppe 1992, Vogt 1992a, b, Farrell et al. 1993, Schö- ner et al. 1993). At the same time, phytase sup- plementations have also significantly enhanced bone mineralization measured as bone ash con- tent or improved phosphorus utilization. Most of the research on phytase additions has been done by studying corn-soya bean meal (SBM) diets. Here we set out to establish what level of supplemental microbial phytase (A. ni- ger) is sufficient in diets containing wheat, bar- ley, oats, SBM and different additions of mineral phosphorus. Table 1. Composition (%) of the basal diets with lowest phosphate addition. Trial I Trial 2 Trial 3 Starter Grower Soya bean meal 32.0 35.0 26.0 32.0 Wheat 25.0 23.0 25.0 25.0 Barley 28.0 25.0 30.0 30.0 Oats 8.7 10.9 13.4 7.1 Rapeseed oil 3.0 3.0 3.0 3.0 Limestone 2.0 2.0 1.8 2.0 Dicalcium phosphate 0.3 0.3 Sodium chloride 0.35 0.3 0.3 0.3 Vitamin and mineral premixes l * 0.5 0.5 0.5 0.5 DL methionine 0.08 0.08 0.08 0.08 L lysine 0.03 0.03 0.03 0.03 Calculated ME MJ/kg 11.55 11.50 11.75 11.60 Analysed dry matter 87.7 88.1 87.7 90.1 crude protein 22,5 22.2 20.4 20.7 ether extract 5.0 5.7 5.4 5.2 crude fibre 4.5 4.6 3.7 4.4 ash 4.8 4.9 4.6 4.8 11 Supplied per kilogram of diet: 14000 IU vitamin A, 1700 IU vitamin D, 30 mg vitamin E, 1 mg vitamin K, Img thiamin, 6mg riboflavin, 20 pg vitamin B |2 , 3mg pyridoxine, 40 mg niacin, 10 mg pantothenic acid, 0.5 mg folic acid, 0,3 mg biotin, 500 mg choline cloride, 20 mg Fe, 30 mg Zn, 50 mg Mn, 5 mg Cu, 0.5 mg 1 Material and methods Animals and housing Three trials were conducted on 5100 Ross broiler chicks which were sexed and allotted to treat- ments when one day old. In Trials I and 2 the birds were housed in floor pens and in Trial 3 in a 3-tier battery. Housing conditions (temperature, lighting) were as described by Kiiskinen (1983). Peat was used as litter and the experiments lasted for 37, 37 and 35 days, respectively. Feed and water were supplied ad libitum. Experimental design and diets Trial I comprised eight groups with four replicate pens (6 m 2), each holding 60 birds (30 males, 30 females). The basal composition of the SBM-grain diets (Table 1)was similar for all groups excluding supplementations, which were as follows: 1 2 3 4 5 6 7 8Group Phytase PU/g 0 250 500 500 500 750 1000 0 Mineral P% 0.05 0,05 0.05 0.13 0.21 0.05 0.05 0.30 Microbial phytase was produced by Alko Bio- technology (Rajamäki, Finland). One PU (phytase unit) is the amount of enzyme that liberates one nmol of inorganic P from sodium phytate per minute at pH 5 and 37°C. The added mineral P was derived from dicalcium phosphate in all tri- als. The calculated contents of Ca and P were 0.96- 0.97% and 0.45-0.71%, respectively (Table 2). The lowest dietary level of available phosphorus 458 Agricultural Science in Finland 3 (1994) Table 2. Calcium and phosphorus contents of diets. Added dicalcium Calcium Phosphorus Available phosphate % % P % % Calc. Anal. Calc. Anal. Calc. Trial 1 Diets 1-3 0.3 0.97 0.91 0.45 0.49 0.17 ” 4 0.75 0.96 0.88 0.53 0.56 0.25 ” 5 1.25 0.97 0.88 0.61 0.66 0.33 ” 6-7 0.3 0.97 0.92 0.45 0.52 0.17 ” 8 1.35 0.96 0.87 0.71 0.78 0.45 Trial 2 Starters Group 1-3 0.3 0.97 0.99 0.45 0.50 0.17 ” 4-5 0.6 0.97 0.98 0.50 0.56 0.22 ” 6 1.7 0.99 1.04 0.69 0.72 0.41 Growers Group 1-3 - 0.80 0.81 0.37 0.44 0.11 ” 4-5 0.3 0.80 0.79 0.42 0.49 0.16 “ 6 1,4 0.81 0.77 0.61 0.67 0.35 Trial 3 Diets 1-2 - 0.88 1.00 0.42 0.48 0.16 ” 3-5 0.3 0.88 1.01 0.47 0.55 0.21 ” 6-7 0.6 0.89 1.00 0.52 0.60 0.26 ” 8 1.6 0.92 1.05 0,69 0.79 0.43 (AP) was 0.17% and the highest level 0.45% (pos- itive control). The latter value represents the prac- tical dietary level and complies with recommen- dations (NRC 1984, Salo et al. 1990). The diets in this trial and the other two were cold (about 50°C) pelleted without hot steam. Trial 2 was conducted on six groups with eight replicates (62 birds) each. The pens were smaller (4 m 2) than those in Trial 1, and half of them contained males and half females. The chicks were first fed a starter diet (0-2.5 weeks) and then a grower diet (2.5-5.5 weeks) (Table 1). The ex- perimental groups with dietary supplementations were as follows: Group 12 3 4 5 6 Phytase PU/g 0 500 1000 0 500 0 Mineral P% in starter 0.05 0.05 0.05 0.10 0.10 0.29 in grower 0 0 0 0.05 0,05 0.24 The calculated mineral contents in the starters were 0.97-0.99% for Ca, 0.45-0.69% for P and 0.17-0.41% for AP (Table 2). The corresponding levels in the growers were 0.80-0.81%, 0.37- 0.61% and 0.11-0.35%, respectively. The main purpose of Trial 3 was to determine the retention of P with basal diets similar to those used in Trials 1-2. Six replicate cages with four birds in each were allotted for each diet. The supplementations were as follows: 12 3 4 5 6 7 8Group PhytasePU/g 0 1000 0 500 1000 0 500 0 Mineral P% 0 0 0.05 0.05 0.05 0.10 0.10 0.30 The Ca and P contents are listed in Table 2. The calculated Ca levels were 0.88-0.92%, the total P levels 0.42-0.69% and the AP levels 0.16- 0.43%. 459 Agricultural Science in Finland 3 (1994) Measurements, chemical analyses and statistics In Trials 1-2 the birds were weighed pen by pen when one day old. At days 16 and 37, the birds were weighed either individually (Trial 1) or pen by pen (Trial 2). The birds in Trial 3 were weighed individually when one day and 35 days old. Feed intake per replicate (pen, cage) was measured between the weighings. The chickens were starved for 12 hours before slaughter. Dead birds were recorded and weighed. In the slaugh- ter house, 16 carcasses were taken from each group. Both tibias were removed and cleaned be- fore being measured for length and weight (Trial 3) and analysed for ash and phosphorus (Trial 1) contents. In Trial 3, the retention ofP and Ca was deter- mined when the chicks were four weeks old. Weighed amounts of diets were supplied daily, and all excreta were collected over three days. The excreta were weighed, oven-dried at 60°C and ground before analysis. Proximate feed Ca and P analyses were per- formed for the experimental diets. Calcium and P were also analysed in cereals. Calcium was ana- lysed with an atomic absorption spectrophotome- ter and P with a photometer after a colour reac- tion with ammonium vanadate. The same method was used to determine the P concentration in tib- ia ash. The cleaned tibias were ashed at 600°C 16 hours after crushing and ether extraction. The phytic acid content and phytase activity in cereals were determined in Alko’s laboratory. Phytic acid (inositol hexaphosphate) was sepa- rated after HCI extraction by ion exchange and analysed by ion pair C reverse phase HPLC (Sandberg and Ahderinne 1986). Phytase activ- ity was determined from the colour formed by the reduction of a phosphomolybdate complex (Chen et al. 1956). A phytase unit (PU) is the amount of enzyme which liberates, under stand- ard conditions, 1 nmol of inorganic phosphate from sodium phytate in one minute. Analysis of variance was used for the statisti- cal inference. The basic idea of analysis of vari- ance is to divide the total variation in the re- sponse variable into portions associated with cer- tain factors defined by the scheme used for clas- sifying the data. Here, these factors or sources of variation were primarily the treatments and the sex of the birds. The experimental unit for the treatments in all the trials was a pen or a cage, and in Trial 2, in particular, the experimental unit for a treatment and sex combination was a pen. In Trials 1 and 3, the birds were weighed individ- ually, and the males and females were not sepa- rated into different pens; the experimental unit for the sex of the bird was a bird. Some of the birds died before the experiments were finished, and from the beginning of the trials there were uneven numbers of males and females in some of the pens or cages. This resulted in unbalanced experiments. In such situations, residual maxi- mum likelihood (REML) estimates were used as suggested by Milliken and Johnson (1984) in- stead of the usual moment estimates. The SAS MIXED-procedure (SAS 1992) was used for an- alysing the unbalanced data and the SAS GLM procedure (SAS 1990) for the balanced data. The main interest in terms of statistical infer- ence lay in the contrast analysis. In Trial 1, or- thogonal polynomials were used to investigate the trends over levels of phytase when the level of mineral P was 0.05%. Linear, quadratic, cubic and even quartic trends were tested. In Trial 2, the main interest was in comparing the two lev- els of phytase, namely 0 and 500 PU/g and to compare the two levels of mineral P combina- tions, namely 0.05%/0% and 0.10%/0.05% (in starter/in grower). The phytase x phosphorus in- teraction was also tested. In Trial 3, two trends were of interest. In groups where the mineral P concentration was 0.05% the linear and quadratic trends over phytase levels were tested; when phytase was 0 PU/g the linear and quadratic trends over the levels of mineral P were tested. Results and discussion The analysed total P contents of the diets (0.44- 0.79%), which were higher than the calculated ones (Table 2) were derived from the P contents 460 Agricultural Science in Finland 3 (1994) Table 3. Ca, P and phytin-P contents and phytase activity in cereals and soya bean meal. Phytic P% bound Phytase Ca P acid 11 in phytic acitivity % in dry matter % acid PU/g DM2) Trial 1 Wheat 0.044 0,43 0.55 0.16 560 Barley 0.046 0.44 0.61 0.17 480 Oats 0.065 0,42 0.49 0.14 65 Soya bean meal 0.331 0.67 0.91 0.26 5 Trial 2 Wheat 0.041 0.42 - - 625 Barley 0.043 0.45 - - 235 Oats 0.071 0.40 29 Soya bean meal 0.245 0.76 - - - " inositolhexaphosphate 2) PU = phytase unit, DM = dry matter (0.40-0.45% in dry matter, Table 3) of the cere- als which were higher than the content (0.35%) used in the calculations (Salo et al. 1990). The cereals in the diets of Trial 1 contained 0.49- O. phytic acid, which amounts to 0.14-0.17% phytate P (Table 3). Phytate P accounted for 37- 39% of the total P of grain, which is lower than the 56-73% presented by Nelson et al. (1968 a) and Lantzsch (1990). Soya bean meal (Trial 1) contained 0.91% phytic acid and 0.26% phytate P, or 39% of total P. This figure too is lower than the 56-61% given by the above authors. Phytase activity in grain was highest in wheat and lowest in oats (Table 3). The order of the cereals is consistent with the findings of Moll- GAARD et al. (1946). From the proportions of ce- reals in the basal diets of Trials I and 2, the natural phytase activities of the diets should have been 280 and 205-230 PU/g, respectively. Ac- cording to the phytase activity determined in the diets of Trial 2 (750-1200 PU/g depending on the supplementation), the intrinsic activity of phytase in the diets was 200-250 PU/g. In all trials, chicks fed the phytase supplement- ed diets gained more weight than those fed the diets with no or very low (0.05%) additional phos- phorus (Tables 4-6). Compared with the negative control groups fed a supplementary level of0.05% mineral P throughout the growing period or in the starter diet only the phytase additions increased final body weight by 4-7% (Tables 4 and 5). Orthogonal polynomial comparison showed a lin- ear effect of phytase additions on live weight at 16 (P < 0.001) and 37 days (P <0.01) in Trial 1. Also in Trial 2, phytase significantly (P < 0.05) increased final body weight, and its effect on the 16-day weight approached significance (P < 0.07). It would seem that positive growth responses might be obtained with phytase supplementations of up to 1000 PU/g. The same growth rate was found by adding 0.10% or 0.13% inorganic Pand 500 PU/g phytase (Tables 4 and 5). A significant (P < 0.05) difference between the P supplemen- tations of 0.05% and 0.10% was noted in Trial 2. The phytase x phosphorus interaction was not found in that trial. The treatment x sex interac- tion in growth rate was not found in Trials 1 and 2. Certain combinations of supplemental phytase and mineral P gave similar and even higher final body weights than the supplemental mineral P levels of 0.24-0.30% in the positive control di- ets. Most previous studies with phytase have been done using corn-based diets in which the activity of natural phytase is relatively low. Therefore, when added to corn-based low-phosphorus diets (0.35-0.55% total P), phytase supplementations have produced weight gains in broilers (4-6 weeks) up to 15—47% higher than those obtained 461 Agricultural Science in Finland 3 (1994) Table 4. Performance of birds and tibia values (Trial 1). Diet I 2345678 SE Mineral P add. % Phytase add. PU/g 0.05 0,05 0,05 0.13 0.21 0.05 0.05 0.30 0 250 500 500 500 750 1000 00 Live weight g 16 days 418 450 476 495 484 474 504 478 8.6 1742 1742 1706 1744 1673 22.0 40.839.8 38.740.9 39.31.26 ” 37 ” 1629 1695 1697 Feed intake 1-16 ” 34.3 38.0 39.134.3 38.0 39.1 g/day 17-37” 116 125 123 125 127 125 126 125 1,26 1.441.44 1.441.41 1.440.024 2.102.11 2.122.13 2.210.024 1.921.93 1.941.94 2.000.020 3.33.3 4.63.3 3.80.44 FCR 1-16” 1.46 1.48 1.44 kg/kg 17-37 ” 2.06 2.10 2.12 1-37” 1.91 1.95 1.94 Mortality % 1-37 7.3 4.6 4.2 Tibia length cm 8.9 9.0 9.1 9.3 9.2 9.2 9,2 9.0 0.10 54.9 55.4 54.8 55.2 55.7 0.43 20.1 20.1 20.1 19.8 19.6 0.09 ash % 54.9 54.9 55.1 P % in ash 19.5 19.9 19.9 SE = standard error of mean FCR = feed conversion ratio with the basal diets (Simons et al. 1990, Swick and Ivey 1990, Vogt 1992a, b, Schöner and Hoppe 1992, Schöner et al. 1993). When wheat has been included in the diets, the growth re- sponses have been comparable to the results of our study (Zyla et al. 1989, Schöner and Hoppe 1992. Broz et al. 1992). The faster growth of the birds fed the phytase supplemented diets or the positive control diets was largely due to their feed intake being higher than that of the negative controls (Tables 4-6). In Trial 1, the daily feed intake increased linearly (P < 0.001) as a result of phytase addition. The same happened in Trial 2 owing to phytase addi- Table 5. Performance of birds and tibia values (Trial 2). Diet 1 Mineral P add. % in starter 0.05 2 3 4 5 6 0.05 0,05 0,10 0.10 0.29 grower 0.05 0,05 0.24 Phytase add. PU/g 500 1000 500 SE Live weight g 16 days 496 518 517 510 515 530 7.5 37 ” 1611 1680 1687 1733 1749 18.01710 Feed intake 1-16” g/day 17-37 ” FCR 1-16 ” kg/kg 17-37 ” 41.4 43.6 43.8 42.7 43.4 45.2 1.06 113 116 118 118 120 127 1,06 1.47 1.47 1.48 1.46 1.44 1.48 0.017 2.20 0.0172.15 2.13 2.08 2.13 2.08 1-37 ” 1.95 1.93 1.91 1.93 1.90 1.99 0.013 3.8 0.553.8 5.2 3.6 3.0 7.9Mortality % 1-37 ” Tibia length cm ash % 9.2 9.2 9.2 9.2 9.3 9.2 0,08 53.8 54.8 54.7 55.2 55.1 56.1 0.35 SE = standard error of mean FCR = feed conversion ratio 462 Agricultural Science in Finland 3 (1994) Table 6. Performance of birds, tibia values and utilization of minerals (Trial 3). Diet 1 2 3 4 5 6 7 8 SE Mineral P add. % Phytase add. PU/g 0.05 0.05 0.05 0.10 0.10 0.3 1000 500 1000 500 Live weight g 35 days 1135 1460 1451 Feed intake g/bird/d 54 70 7254 70 72 FCRkg/kg 1.89 1.81 1.88 Tibia weight g 7.2 11.0 9.8 length cm 7.8 8.6 8.6 ash % 51.0 55.1 55.6 Apparent retention of P and Ca P intake g 4.4.7 6.5 7.2 Faecal P excretion g 2.3 2.6 3.5 P retention g 2.4 3.9 3.7 P retention % 50,9 60.0 50.6 Faecal P g/kg DM 7.7 6.7 8.5 Ca intake g 9.7 13.5 13.0 Faecal Ca excretion g 6.0 7.7 7.6 Ca retention g 3.7 5.8 5.43.7 5.8 5.4 Ca retention % 38.2 43.0 41.2 1502 1490 1538 1522 1498 39.6 72 74 77 74 74 1.5474 77 74 74 1.54 1.82 1.83 1.87 1.83 1.82 0.03 11.0 11.2 10.9 12.1 11.5 0.58 8.8 8.7 8.7 8.8 8.8 0.10 56.1 56.8 56.5 56.8 56.8 0.37 7.2 7,4 8.18.3 10.90.17 3.63.6 4.74.6 7.20.13 3.63.8 3.43.5 3.70.13 50.151.0 42.342.8 33.91.34 9.09.0 10.511.1 16.50.24 13.114.0 13.713.8 14.70.32 7.88.2 8.88.8 9.20.28 5.35.8 4.95.0 5.50.21 40.741.7 36.236.6 37.51.35 SE = standard error of mean FCR = feed conversion ratio tion (500 PU/g, P < 0.05) and the higher dietary P level (P < 0.01). In the supplemented groups of Trial 1, the feed conversion ratio (FCR) was slight- ly, but not significantly, higher than that of the negative control group (Table 4). In contrast, in Trial 2 the FCR of the supplemented groups, ex- cluding the positive control, was lower than that of the negative control group (Table 5). Both phytase addition (500 PU/g) and the elevated P level significantly (P < 0.05) decreased the FCR, mainly, however, during the growing period (17- 37 days). Also in Trial 3, the FCR was decreased as a result of the supplementations; significant differences were not, however, found (Table 6). In previous studies with broiler chicks, feed in- take rose markedly due to phytase supplementa- tion but the FCR was not significantly affected (Zyla et al. 1989,Simons et al. 1990, Broz et al. 1992, Schöner and Hoppe 1992, Vogt 1992a, b). In Trial 1, supplemental phytase increased tib- ia length linearly (P < 0.05) and the phosphorus content of tibia ash quadratically (P < 0.001, Table 4). Tibia ash values ranging from 54.8% to 55.7% were not affected by phytase addition. In Trial 2, no differences in tibia length were found but differences in tibia ash between the negative control and the supplemented groups were clear- er than in Trial 1, and the extreme values (nega- tive and positive controls) differed significantly (P < 0.001, Table 5). The different responses to the supplementations in Trials 1 and 2 could have been due to the average lower available P con- tent and lower natural phytase activity of the ba- sal diet of Trial 2. The increase in mineral P from 0.05% to 0.10% increased the tibia ash content (P < 0.05). Adding phytase or inorganic P or both to the basal diet with no mineral P supplementa- tion promoted bone mineralization whether ex- pressed as tibia weight, tibia length or tibia ash (Table 6, Trial 3). The tibia ash content was 51.0% for the non-supplemented group and 55.1-56.8% for the supplemented groups. According to re- ports where the basal diet has contained 0.5% or less total phosphorus, phytase supplementa- tions have increased the tibia ash content by 3-6 percentage units (Kiiskinen and Puronen 1990, 463 Agricultural Science in Finland 3 (1994) Broz et al. 1992, Vogt 1992a, b, Parrel et al. 1993). In the comparison with orthogonal con- trasts, adding phytase to the diet with 0.05% mineral P increased tibia ash content linearly (P < 0.05); the effect on tibia weight was nearly significant (P = 0.06). In contrast, mineral P ad- ditions of up to 0.10% in the basal diet with no phytase addition increased all tibia values linear- ly (P < 0.001) and tibia length (P < 0.01) and tibia ash (P < 0.001) quadratically. Supplementations of the basal diet in Trial 3 resulted in a significant (P < 0.05) increase in P and Ca retention due to increased feed intake and mineral supply (Table 6). The utilization of P (percentage retention of intake) increased by ap- proximately 9 percentage units (50.9%/60.0%), when the basal diet was supplemented with phytase (1000 PU/g). Similar P utilization values of 50-60% and improvements of 5-15 percent- age units due to phytase supplementation have been reported in broiler chicks fed low phospho- rus (0.35-0.5%) diets (Simons et al. 1990, Schö- ner and Hoppe 1992, Schöner et al. 1993, Far- rell et al. 1993). When 0.05% mineral P was added to the basal diet, utilization of P did not change but additions of 0.10% and 0.30% miner- al P reduced it to 42.3% and 33.9%, respectively. Phytase supplementation did not affect retention or utilization of P when 0.05% or 0.10% mineral P was added to the diet. Phytase reduced the fae- cal P content from 7.7 g/kg DM to 6.7 g/kg DM when added to the basal diet with no mineral P but did not have an effect in the diet with 0.05% mineral P. Supplementation of mineral P increased faecal P excretion linearly (P < 0.001) from 2.3 g to 3.5, 4.7 and 7.2 g and faecal P content from 7.7 g/kg DM to 8.5, 10.5 and 16.5 g/kg DM (P < 0.001), respectively. When inorganic P (0.05 and 0.10%) was added to the diet, phytase did not affect faecal P or Ca excretion significantly. Compared with the positive control diet, savings in P excretion with the other supplemented diets were 35-64%. According to Huyghebaert and De Groote (1992), P excretion can be reduced by 30-50% by supplementing the diet with mi- crobial phytase. Phytase supplementation (1000 PU/g) in the basal diet increased the utilization of Ca by 4.8 percentage units but the difference was not significant. This obervation is supported by certain other authors (Simons et al. 1990, Schöner et al. 1991, 1993), who found that sup- plemental phytase markedly increased the utili- zation of Ca in low-calcium (0.6%) diets. Addi- tion of phytase to the diets with supplementation of 0.3% or 0.6% dicalcium phosphate did not affect the utilization of Ca. In addition to the intrinsic phytase activity de- rived from cereals, the results of this study were obviously affected by the calcium level and Ca:P ratio of the diets. High dietary levels of Ca and high Ca:P ratios cause a reduction in both feed consumption and body weight gains (Vandepop- uliere et al. 1961, Waldroup et al. 1964, Nel- son et al. 1965, Edwards 1982, Schöner et al. 1993). An increased Ca content has been found to reduce the activity of phytase (McCuaig et al. 1972) and the retention of P from phytales (Ed- wards 1982, Schöner et al. 1993). In the diets used here the Ca content was 0.8-1.0% and the P content of the basal diets (0-0.1% mineral P) was 0.44-0.60% (Ca:P 1.7-1.8). It is very proba- ble that a lower Ca level of 0.6-0.7% would have given a better response to phytase addition. Schöner et al. (1993) found that increasing the dietary Ca level from 0.6% to 0.9% in low-phos- phorus diets had negative effects on the utiliza- tion of phosphorus. Considering the results obtained here and the findings of earlier studies, we conclude that the weight gain of birds and P utilization and bone mineralization can all be improved by adding phytase to broiler diets composed of feed of plant origin and based on wheat, barley and oats. In this way, mineral P supplementation and P waste in manure can be reduced. 464 Agricultural Science in Finland 3 (1994) References Broz, J., Oldale, P., Rychen, G., Schulze, J. & Simoes Nunes, C. 1992. Effects of supplemental phytase on performance and phosphorus utilization in broiler chick- ens reared until market weight. Proceedings 3, XIX World’s Poultry Congress, Amsterdam, p. 435-438. Chen, P.S.Jr., Toribara, T.Y. & Warner, H. 1956. Micro- determination of phosphorus. Analytical Chemistry 28; 1756-1758. Edwards, H.M.Jr. 1982. Phosphorus. 1. Effect of breed and strain on utilization of suboptimal levels of phos- phorus in the ration. Poultry Science 62: 77-84. Farrell, D.J., Martin, E., Thomson, E., Preez, J. du & Bongarts, M. 1993. The beneficial effects of a micro- bial feed phytase in diets of broiler chickens and duck- lings. Journal of Animal Physiology and Animal Nu- trition 69: 278-283. Huyghebaert, G. & De Groote, G. 1992. The definition of Natuphos-5000 phytase in terms of relative P-val- ues for least-cost formulation of broiler diets. Pro- ceedings 3, XIX World’s Poultry Congress, Amster- dam. p. 455-456. Kiiskinen, T. 1983. The effect of diets supplemented with Regent rapeseed meal on performance ofbroiler chicks. Annales Agriculturae Fenniae 22: 206-213. - & Piironen, J. 1990. Effects of phytase supplementa- tion on utilization of phosphorus in chicken diets. Pro- ceedings VIII European Poultry Conference, Barcelo- na. p. 376-380. Lantzsch, H.-J. 1990. Untersuchungen iiber ernährungs- physiologische Effekte des Phytats bei Monogastriern (Ratte, Schwein). Übersichten zur Tieremährung 18: 197-212. McCuaig, L.W., Davies, M.I. & Mozok, L. 1972. Intesti- nal alkaline phosphatase and phytase of chicks: Effect of dietary magnesium, calcium, phosphorus and thy- roactive casein. Poultry Science 51: 526-530. Milliken, G. & Johnson, D. 1984. Analysis of Messy Data. Vol. I: Designed experiments. 473 p. Van Nos- trand Reinhold. New York. MOLLGAARD, H., LORENGEN, K., HANSEN, I.G. & CHRIS- TENSEN, P.E. 1946. On phytic acid, its importance in metabolism and its enzymic cleavage in bread supple- mented with calcium. Biochemistry Journal 40: 589- 603. Nelson, T.S., Ferrara, L.W. & Storer, N.L. 1968a. Phytate phosphorus content of feed ingredients derived from plants. Poultry Science 47: 1372-1374. -, Hargus, W.A., Storer, N. & Walker, A.C. 1965.The influence of calcium on phosphorus utilization by chicks. Poultry Science 44: 1508-1513. -, Shieh, T.R., Wodzinski, RJ. & Ware, J.H. 1968b. The availability of phytate phosphorus in soybean meal before and after treatment with a mold phytase. Poul- try Science 47: 1842-1848. -, Shieh, T.R., Wodzinski, RJ. & Ware, J.H. 1971. Ef- fect of supplemental phytase on the utilization of phytate phosphorus by chicks. Journal of Nutrition 101: 1289-1294. NRC 1984. Nutrient Requirements of Poultry. 71 p. Eight Revised Edition. National Academy Press. Washing- ton, D.C. Salo, M.-L., Tuori, M, & Kiiskinen, T. 1990. Rehutaulu- kot jaruokintanormit. 70 p. 3. Ed. Yliopistopaino. Hel- sinki. Sandberg, A.-S. & Ahderinne, R. 1986. HPLC method for determination of inositol tri-, tetra-, penta- and hex- aphosphates in foods and intestinal contents. Journal of Food Science 51: 547-550. SAS 1990. SAS/STAT User’s Guide, 1686 p. Vers, 6, 4th ed., Vol. 2. SAS Inst. Inc. Cary, NC, USA. - 1992. Technical Report P-229. SAS/STAT Software: Changes and Enhancements, Release 6.07: 620 p. SAS Inst. Inc. Cary, NC, USA. Saylor, W.W., Bartnikowski, A. & Spencer, T.L. 1991. Improved performance of broiler chicks fed diets con- taining phytase. Poultry Science 70. Supplement 1 p. 104(Abstract). Schöner, F.J. & Hoppe, P.P. 1992. Microbial phytase, a tool to alleviate environmental phosphorus pollution from broiler production. Proceedings 3, XIX World’s Poultry Congress, Amsterdam, p. 429-432. -, Hoppe, P.P. & Schwarz, G. 1991. Vergleich der Ef- fekte von mikrobieller Phytase und anorganischem Phosphat auf die Leistungen und die Retention von Phosphor, Calcium und Rohasche bei Masthiihnerkuken in der Anfangsmast. Journal of Animal Physiology and Animal Nutrition 66: 248-255. -, Hoppe, P.P, Schwarz, G. & Wiesche, H. 1993. Ver- gleich von mikrobieller Phytase und anorganischem Phosphat bei Masthahnenkiiken: Wirkungen auf die Mastleistungen und die Mineralsroffretention bei vari- erter Calcium-Versorgung. Journal of Animal Physiol- ogy and Animal Nutrition 69: 235-244. Simons, P.C.M., Versteegh, H.A.J., Jongbloed, A.W., Kemme, P.A., Slump, P., Bos, K.D., Wolters, M.G.E., Beudeker, R.F. & Verschoor, G.J. 1990. Improve- ment of phosphorus availability by microbial phytase in broilers and pigs. British Journal of Nutrition 64: 525-540. Swick, R.A. & Ivey, F.J. 1990. Effect of dietary phytase addition on broiler performance in phosphorus defi- cient diets. Poultry Science 69. Supplement 1. p. 133 (Abstract). Vandepopuliere, J.M., Ammermann, C.B. & Harms, R.H. 1961. The relationship of calcium-phosphorus ratios on the utilization ofplant and inorganic phosphorus by the chick. Poultry Science 40: 951-957. Vogt, H. 1992a. Einsatz von Phytase im Broilermastfut- ter mit unterschiedlichem Phosphorgehalt. Archiv fiir Gefliigelkunde 56: 93-98. -1992b. Einsatz von Phytase im Broilermastfutter mit unterschiedlichem Phosphorgehalt: 2. Versuch. Archiv 465 Agricultural Science in Finland 3 (1994) fiir Gefliigelkunde 56: 222-226. Waldroup,P.W., Ammermann, C.B. & Harms, R.H. 1964. The availability of phytic acid phosphorus for chicks. 3. Effect of calcium and vitamin D 3 levels on the utili- zation of calcium phytate. Poultry Science 43: 926- 931. Zyla, K., Koreleski, J. & Kujawski, M. 1989. Dephos- phorylation of phytate compounds by means of acid phosphatase from Aspergillus niger. Journal of the Sci- ence of Food and Agriculture 49: 315-324. Manuscript received December 1993 SELOSTUS Fytaasilisäyksen vaikutukset broilerien rehussa Tuomo Kiiskinen, Jari Piironen ja Tiina Hakonen Maatalouden tutkimuskeskus ja Oy Alko Ab Sienifytaasin (Aspergillus niger ) lisäyksen vaikutusta broi- leripoikasten (0-5,5 vk) kasvuun, rehunkulutukseen, luus- ton mineraalisoitumiseen ja fosforin hyväksikäyttöön tut- kittiin kolmessa kokeessa, joissa oli yhteensä 5100 poi- kasta. Soija-viljapohjainen perusrehu sisälsi lisättyä ki- vennäisfosforia 0-0,1 % (negatiivinen vertailurehu) ent- syymilisäyksen ollessa 250-1000 fytaasiyksikköä (PU) re- hugrammassa. Positiivisessa vertailurehussa kivennäisfos- forin lisäys oli 0,24-0,30 %. Fytaasin lisääminen perusrehuun, jossa ei ollut lain- kaan tai hyvin vähän (0,05 %) lisättyä kivennäisfosforia, lisäsi selvästi broilerien rehunkulutusta ja kasvua, Fytaa- silisäyksellä 1000 PU/g saavutettiin sama kasvutulos kuin positiivisella vertailurehulla. Sääriluusta tehdyt mittauk- set ja määritykset osoittivat, ettei fytaasilisäyksellä ollut merkittävää vaikutusta luun mineralisoitumiseen, jos re- huun lisättiin kivennäisfosforia. Ellei rehuun lisätty ki- vennäisfosforia fytaasilisäyksen vaikutus sääriluuarvoihin oli huomattava. Fytaasilisäys (1000 PU/g) paransi fosfo- rin hyväksikäyttöä perusrehussa ja vähensi fosforin eritty- mistä ulosteista. Koetulosten mukaan kivennäisfosforin käyttöä voidaan huomattavasti vähentää broilerien rehuis- sa lisäämällä niihin fytaasia, jolloin myös lannassa eritet- ty fosfori vähenee. 466 Agricultural Science in Finland 3 (1994)